|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
04-11-2017, 11:47 AM | #1 |
Not Yet Wild
Join Date: Apr 2017
Posts: 6
|
1999 EZgo TXT no power on hills
I am working on an EZgo project cart. batteries are reading 6 to 6.4 volts. contoller is new and cables have been upgraded to 2 ga. I have 37.2V at the controller. I goes good inf fwd and rev on flat surfaces, but will not do even a slight incline?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-11-2017, 12:56 PM | #2 |
Gone Insane
Join Date: Oct 2015
Location: TN/NC/GA Tri-state area
Posts: 3,952
|
Re: 1999 EZgo TXT no power on hills
Make sure that you did not wire up a sepex cart like a series cart. It could result in that symptom.
|
04-11-2017, 02:06 PM | #3 |
Gone Wild
Join Date: Apr 2013
Location: Deep Run, NC
Posts: 2,544
|
Re: 1999 EZgo TXT no power on hills
37.2v is a little low for pack voltage. I would suspect a bad battery or two. Check each one under a load and see how much they drop. Your pack should be 38.2 volt and only drop no more than 3-4 volts when driving.
Sent from my SM-G930R4 using Tapatalk |
04-11-2017, 02:22 PM | #4 |
Gone Wild
Join Date: Jul 2011
Location: Rhode Island
Posts: 489
|
Re: 1999 EZgo TXT no power on hills
Load test each battery. How old are the batteries?
|
04-12-2017, 03:21 PM | #5 |
Not Yet Wild
Join Date: Apr 2017
Posts: 6
|
Re: 1999 EZgo TXT no power on hills
they are suppose to be fairly new with very little usage. can the load test be done at an auto supply (auto zane, napa etc.) from what I have heard somehow it has to be load tested while driving?
|
04-12-2017, 03:25 PM | #6 |
Not Yet Wild
Join Date: Apr 2017
Posts: 6
|
Re: 1999 EZgo TXT no power on hills
My neighbor and I swapped his batteries to put into mine, they read nearly identical to mine and it would not climb. But he has no problem in his cart as he drove it up my drive to do the swap
|
04-12-2017, 03:26 PM | #7 |
Not Yet Wild
Join Date: Apr 2017
Posts: 6
|
Re: 1999 EZgo TXT no power on hills
not sure what you refer to in sepex cart va series
|
04-12-2017, 03:27 PM | #8 |
Gone Wild
Join Date: Nov 2013
Location: North Augusta SC
Posts: 273
|
Re: 1999 EZgo TXT no power on hills
clip the leads of a DVM on your battery post, then go up a hill and watch the reading. do this on each battery.
|
04-12-2017, 03:29 PM | #9 |
Gone Wild
Join Date: Nov 2013
Location: North Augusta SC
Posts: 273
|
Re: 1999 EZgo TXT no power on hills
|
04-13-2017, 01:18 PM | #10 |
Not Yet Wild
Join Date: Apr 2017
Posts: 6
|
Re: 1999 EZgo TXT no power on hills
not sure where to find "stickies"
|
|
|
Similar Threads | ||||
Thread | Forum | |||
1999 EZGO TXT no power to the motor | Electric EZGO | |||
1999 Ezgo slow up hills | Electric EZGO | |||
1993 EZGo lacking power up hills with new batteries | Electric EZGO | |||
'96 EZGO - slight power loss up hills | Gas EZGO | |||
1999 G16 dies on hills | Gas Yamaha |