|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
07-19-2017, 10:16 AM | #1 |
Not Yet Wild
Join Date: Jul 2017
Posts: 10
|
Ezgo problems,
2006 36volt txt. Took the cart out and it slowly stopped going, I was in tall grass. It tried to go again after a few minutes. Now nothing at all. The solenoid does not click, I get pack volt on the battery side of the sol. And 3.5 volts on the other side. The resistor gets very hot.
I replaced the foot switch, f&r switch, and solenoid. What else am I missing? |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-19-2017, 10:17 AM | #2 |
Not Yet Wild
Join Date: Jul 2017
Posts: 10
|
Re: Ezgo problems, help!
There is also no reed switch
|
07-19-2017, 10:29 AM | #3 | |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: Ezgo problems, help!
Quote:
Attached a a schematic with solenoid activation circuit highlighted. |
|
07-19-2017, 10:52 AM | #4 |
Not Yet Wild
Join Date: Jul 2017
Posts: 10
|
Re: Ezgo problems, help!
You know...i haven't checked the keyswitch.
|
07-19-2017, 10:57 AM | #5 | |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,406
|
Re: Ezgo problems, help!
Quote:
|
|
07-19-2017, 11:21 AM | #6 |
Not Yet Wild
Join Date: Jul 2017
Posts: 10
|
Re: Ezgo problems, help!
It stays hot, even when with the key off? I'm looking for key switch diagrams right now
|
07-19-2017, 11:50 AM | #7 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,406
|
Re: Ezgo problems, help!
keyswitch diagram
|
07-19-2017, 12:10 PM | #8 |
Not Yet Wild
Join Date: Jul 2017
Posts: 10
|
Re: Ezgo problems, help!
So the key switch reads pack volt on b, then pack volt on I when the key is on. The solenoid still won't click, and the resistor gets hot, even when the key isn't on? Not sure what else to troubleshoot
|
07-19-2017, 12:34 PM | #9 |
Not Yet Wild
Join Date: Jul 2017
Posts: 10
|
Re: Ezgo problems,
I got .7 volts lower than pack voltage on the controller side of the solenoid, but nothing on the small terminals
|
07-19-2017, 12:45 PM | #10 | |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,406
|
Re: Ezgo problems,
Quote:
My question would be is the controller getting power to the red wire in the molex? if yes how? |
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Ezgo pds problems no go! | Electric EZGO | |||
02 ezgo problems | Electric EZGO | |||
84 EZGO Problems | Gas EZGO | |||
06 EZGO PDS problems | Electric EZGO |