|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
04-21-2018, 01:43 PM | #1 |
Not Yet Wild
Join Date: Mar 2018
Location: MA
Posts: 22
|
2001 TXT ITS issue?
Hello, so have been dealing with the same issue for awhile. The cart would go slow then fast. I replaced a lot of parts including the ITS and still had the same issue so I decided to upgrade the controller and installed a Alltrax XCT500. Well the install went well but I still have an issue. The controller is blinking 4-green which is ezgo ITS. I get 6.91v when checking black to white in the ITS box and I get 11.10 when going from white to B-.
Any ideas on what may be the issue? Is it possible the new ITS I bought is bad also? I am stuck on what to look at next. Thank you, |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-21-2018, 03:01 PM | #2 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,418
|
Re: 2001 TXT ITS issue? Need Help
Hello -
There is a 4 pin plug in the harness between the pedal box and the controller. This connection is a notorious place for corrosion to interfere with throttle signal quality. Clean the plug and retry or simply eliminate the plug with some solder and heat shrink |
04-21-2018, 03:12 PM | #3 | |
Not Yet Wild
Join Date: Mar 2018
Location: MA
Posts: 22
|
Re: 2001 TXT ITS issue? Need Help
Quote:
Scotty, thank again for the help. I only see one cable which runs directly from the controller to the ITS Box. I don't see any connectors in the middle. I did a continuity test on each end of the cable and its rang out ok. Should I replace the cable? I already replaced the ITS and Micro switch. Best regards, |
|
04-22-2018, 01:22 PM | #4 |
Not Yet Wild
Join Date: Mar 2018
Location: MA
Posts: 22
|
Re: 2001 TXT ITS issue? Need Help
Anyone have any more ideas?
|
04-23-2018, 10:26 AM | #5 |
Gone Wild
Join Date: Jan 2014
Location: South Georgia
Posts: 1,120
|
Re: 2001 TXT ITS issue?
Double check the cable between the pedal box for a connector or a splice. Just because the wires continuity is good from pedal box to controller will not always reveal problems this cable will cause. Normally there is a small connector involved between the ITS and controller but sometimes the connector has been eliminated with a poorly made splice taped in a bundle with corrosion causing leakage between the conductors.
|
04-23-2018, 11:13 AM | #6 | |
Not Yet Wild
Join Date: Mar 2018
Location: MA
Posts: 22
|
Re: 2001 TXT ITS issue?
Quote:
I ordered a new cable to go from the controller to the ITS. Hopefully this will solve the issue. When I picked up the cart it was snowing and I test drove about 10 times and everything was fine. I brought it home put it in the garage and about a week or two later I went to take it out for a ride and this whole issue started. |
|
04-23-2018, 11:39 AM | #7 | |
Gone Wild
Join Date: Apr 2013
Location: Deep Run, NC
Posts: 2,544
|
Re: 2001 TXT ITS issue?
Quote:
Sent from my SM-G930R4 using Tapatalk |
|
04-23-2018, 02:42 PM | #8 |
Not Yet Wild
Join Date: Mar 2018
Location: MA
Posts: 22
|
Re: 2001 TXT ITS issue?
|
04-24-2018, 07:48 AM | #9 |
Not Yet Wild
Join Date: Mar 2018
Location: MA
Posts: 22
|
Re: 2001 TXT ITS issue?
Good morning, So last nigh I replaced the ITS again as I noticed that the first one I bought was a knock off with a lot of Chinese writing on the bottom. The cart now will go forward and reverse but is still slow. The controller no longer has the code for the ITS but I did notice that once you push the pedal to the floor the green LED starts to flash red.
Does anyone know what this means? I didn't see anything in the book. |
04-24-2018, 08:12 AM | #10 |
Not Yet Wild
Join Date: Mar 2018
Location: MA
Posts: 22
|
Re: 2001 TXT ITS issue?
Some install pic's
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2001 CC DS OBC issue... | Electric Club Car | |||
2001 EZGO TXT Lighting Issue | Electric EZGO | |||
2001 TXT fuel issue | Gas EZGO | |||
2001 TXT power issue | Electric EZGO | |||
2001 Gas TXT Battery Charging Issue | Gas EZGO |