|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
05-22-2018, 07:50 AM | #1 |
Not Yet Wild
Join Date: May 2017
Posts: 3
|
EZGO RXV No power to blue charger wire
This RXV has no action when peddle depressed, no clicks. No power to brake wires, run,tow or otherwise. I have no power at the blue wire coming out of charger port. Have looked at the troubleshooting guide and shows it should have power but does not say what to look for if it does not. The charger for this cart is not working as well. Pack voltage is 47.6. Was hoping this is adequate voltage. Does the controller control the charger? Why no power to blue wire?
Thanks in advance. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-22-2018, 07:54 AM | #2 |
Not Yet Wild
Join Date: May 2017
Posts: 3
|
Re: EZGO RXV No power to blue charger wire
I forgot to mention that all fuses are good.
|
05-22-2018, 08:02 AM | #3 |
Gone Wild
Join Date: Mar 2014
Location: NE Indiana & SW Florida
Posts: 3,238
|
Re: EZGO RXV No power to blue charger wire
Jump a wire from the blue wire to + 48v pack voltage. If back to normal replace the charge port.
|
05-22-2018, 09:29 AM | #4 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: EZGO RXV No power to blue charger wire
|
05-22-2018, 09:35 AM | #5 |
Not Yet Wild
Join Date: May 2017
Posts: 3
|
Re: EZGO RXV No power to blue charger wire
Thank you, That did it.
|
05-22-2018, 11:59 AM | #6 |
Gone Wild
Join Date: Mar 2014
Location: NE Indiana & SW Florida
Posts: 3,238
|
Re: EZGO RXV No power to blue charger wire
Glad to help.
|
06-09-2018, 03:37 PM | #7 | |
Not Yet Wild
Join Date: Jun 2017
Location: Manitoba Canada
Posts: 3
|
Re: EZGO RXV No power to blue charger wire
Quote:
Thanks |
|
06-09-2018, 05:42 PM | #8 |
Resident Curmudgeon
Join Date: Oct 2011
Posts: 1,279
|
Re: EZGO RXV No power to blue charger wire
The battery on the passenger front (Closest to the run/tow switch) has a few wires and a cable going to a terminal towards the front. that's +48V. Positive main basically.
The blue wire is some sort of interlock--theoretically you shouldn't be able to drive with charger plugged in. it shuts the car down when charging. On older models when the charge port fails it sends a 'Charger Connected' fault/warning to the controller even when disconnected from a charger, causing the same symptom--no power, no backup alarm, nothing. Another failure with same symptom is the little black 'cube' with ring terminal that is on the positive main of the pack, with a grey 'phone cable' looking wire, the ring corrodes off and some folks just cut the 'cube' off and replace it with just a ring terminal. Sometimes this shuts the car down, other times it might run but charger no longer accepts it. |
|
|
Similar Threads | ||||
Thread | Forum | |||
Blue wire from solenoid - ezgo txt series | Electric EZGO | |||
accu power lester charger help - wire diagram | Electric Club Car | |||
F&R/Blue controller wire operation | Electric Club Car | |||
Cut the blue wire...... | Test Post | |||
this blue wire???? | Electric EZGO |