|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
09-28-2018, 09:17 AM | #1 |
Not Yet Wild
Join Date: Apr 2017
Posts: 4
|
97 DCS w/ alltrax wheels barely turn
Hey guys, I have a DCS with an alltrax controller that quit putting out power while on a subdivision stroll. Got the cart home jacked the rear end up and pushed the pedal and it seems like it wants to turn but is sluggish and making a clicking type noise every time the axle tries to spin. That being said I dont think its an axle issue because it sounds like the motor is just getting intermittent power. The ITS has been replaced a year ago and tested fine today. I did find the A motor cable to have a heat issue and has been replaced....although could have been like that. The controller does give a green light when powered up but blinks two red when pedal is depressed. Any thoughts?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-28-2018, 11:04 AM | #2 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,187
|
Re: 97 DCS w/ alltrax wheels barely turn
If this is a DCX alltrax 2 red means under temperature and I doubt you are somewhere below 25C. I had the same problem with one and it was sensing voltage on the frame. Make sure you don’t have any wiring grounded to frame and if all that checks out the controller probably is bad.
|
09-28-2018, 11:13 AM | #3 |
Not Yet Wild
Join Date: Apr 2017
Posts: 4
|
Re: 97 DCS w/ alltrax wheels barely turn
Ok so I found the small red resistor wire on the solenoid was damaged/burnt. After replacing it the cart has full power but smoked the wire again! Really stumped now!
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2008 ezgo will run but wheels will not turn | Electric EZGO | |||
Motor won't run/ wheels won't turn | Electric Club Car | |||
I think my son found out why rear wheels do not turn | Electric EZGO | |||
1996 Series DS 48V won't move on ground, wheels barely move on jacks | Electric Club Car | |||
Help! Front wheels wont turn | Electric Club Car |