|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
10-13-2018, 09:53 PM | #1 |
Getting Wild
Join Date: Sep 2018
Posts: 96
|
2000 EZGO TXT PDS with US2200 6 volt batteries charging question
First off, this is the first cart I've owned.I just put 6 new 6 volt US2200 batteries in yesterday. I then plugged in my Powerwise industrial charger. It's the big black and silver one. It started charging at 19 or 20 amps and I left it after going into the house for the night thinking it would be off in the morning. That was at 7:30 in the evening. Well, at 7:30 this morning, it was still on. The amp meter showed about 3 or 4 amps. I checked the pack voltage and it was 45.2. I then decided I better unplug it. I know the relay in the charger works cause when you plug and unplug the charger cord from the cart the charger transformer turns on and off. Shouldn't this charger shut off when the pack is around 45.2 volts? I hope it didn't cause any damage to my batteries. Thinking not since the amperage was so low at the end. I road it for about 15 minutes and put it back on the charger to top it off, and it went back to 45.2 volts and didn't shut off. Was pushing about 3 amps again. Started at 19 or so. I'm scared to leave it on too long for fear of damaging my batteries. Paid $750 for them. What could cause this? I hate to have manually shut it off everytime I charge it. Wonder if the circuit board is bad in the charger and is causing this?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-13-2018, 11:52 PM | #2 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: 2000 EZGO TXT PDS with US2200 6 volt batteries charging question
I think your next move is to try letting it do it's job, give it time to shut down on it's own. 45.x volts is nothing to be alarmed about while charging.
|
10-14-2018, 04:02 AM | #3 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,147
|
Re: 2000 EZGO TXT PDS with US2200 6 volt batteries charging question
I agree. If I remember correctly the US batteries have a higher cutoff than Trojan so it might take a little longer.
|
10-14-2018, 06:44 AM | #4 |
Getting Wild
Join Date: Sep 2018
Posts: 96
|
Re: 2000 EZGO TXT PDS with US2200 6 volt batteries charging question
Ok, I'll let it go a while longer next time and we'll see what happens.
|
10-14-2018, 06:56 AM | #5 |
Gone Mad
Join Date: Oct 2009
Location: Buford, GA
Posts: 8,988
|
Re: 2000 EZGO TXT PDS with US2200 6 volt batteries charging question
Next time should be now.
|
10-14-2018, 09:24 AM | #6 |
Getting Wild
Join Date: Jul 2011
Location: Wellington, Ohio
Posts: 127
|
Re: 2000 EZGO TXT PDS with US2200 6 volt batteries charging question
If I'm not mistaken the power-wise charger will run for a maximum of 16 hours before shutting off. If it was showing 3 or 4 amps the charger was in the finish stage. I would run the charger again and if it runs for more than 16 hours then there is probably an issue with your charger.
Sent from my SM-S903VL using Tapatalk |
10-14-2018, 12:21 PM | #7 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: 2000 EZGO TXT PDS with US2200 6 volt batteries charging question
First, we need to identify which Powerwise charger is being used. Post the model number or a picture of the faceplate.
As for the finish voltage, 45V is the minimum on-charge voltage needed to be reached to fully charge the US Battery batteries. |
10-14-2018, 12:45 PM | #8 |
Getting Wild
Join Date: Sep 2018
Posts: 96
|
Re: 2000 EZGO TXT PDS with US2200 6 volt batteries charging question
It's the model 28115 G04. I put it back on and left it alone and it actually shut off. 😁I checked the pack voltage and it was 38.6 volts. Not sure how long it had been off and resting when I took that reading. Got a lesson in patience. Thanks for all the advice and thoughts on the matter!
|
10-14-2018, 01:18 PM | #9 | |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: 2000 EZGO TXT PDS with US2200 6 volt batteries charging question
Quote:
Here is a SoC chart for USB batteries. The voltage readings are to be taken 12 hours after charger shuts off. (anything between about 8hr and 24hr is close enough) |
|
|
|
Similar Threads | ||||
Thread | Forum | |||
charging 8 volt batteries | Electric Club Car | |||
Charging 8 6 volt batteries??? | Electric Club Car | |||
2000 club car, new batteries. Doesn't stop charging | Electric Club Car | |||
Charging batteries with a 12 volt charger | Electric EZGO | |||
Charging 6 volt batteries | Electric EZGO |