|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
11-08-2018, 07:46 AM | #1 |
Gone Wild
Join Date: Jun 2017
Location: Savannah, GA
Posts: 6,539
|
DPI gen 3 never shuts off
After a full night of charging. Is this normal? The charger stays on even if I unplug it from the cart. Pack voltage is 57.5 and they’re boiling like crazy. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
11-08-2018, 09:10 AM | #2 | |
Gone Wild
Join Date: Apr 2013
Location: Deep Run, NC
Posts: 2,544
|
Re: DPI gen 3 never shuts off
Quote:
Sent from my SM-G930R4 using Tapatalk |
|
11-08-2018, 09:11 AM | #3 |
Gone Wild
Join Date: Jun 2017
Location: Savannah, GA
Posts: 6,539
|
DPI gen 3 never shuts off
The green light is on but the charger runs and runs. It’s a 48v charger on the Trojan algorithm.
Also, the charger won’t even start unless I plug it into the cart before the wall. That seems unusual. It runs as soon as I plug it in but it won’t start putting out any voltage until I unplug it from the wall again. Club Car DS driver’s club #59 |
11-08-2018, 09:33 AM | #4 | |
Gone Wild
Join Date: Apr 2013
Location: Deep Run, NC
Posts: 2,544
|
Re: DPI gen 3 never shuts off
Quote:
Sent from my SM-G930R4 using Tapatalk |
|
11-08-2018, 09:36 AM | #5 |
Gone Wild
Join Date: Jun 2017
Location: Savannah, GA
Posts: 6,539
|
Re: DPI gen 3 never shuts off
Strange. I just got this one used and this is how it was. I had another DPI a while ago but I don’t remember it acting up like this.
Club Car DS driver’s club #59 |
11-08-2018, 09:39 AM | #6 |
Gone Mad
Join Date: Oct 2009
Location: Buford, GA
Posts: 8,988
|
Re: DPI gen 3 never shuts off
Contact DPI. They were very helpful with me.
|
11-08-2018, 10:19 AM | #7 |
Just Gone
Join Date: Sep 2015
Location: North Carolina
Posts: 3,549
|
Re: DPI gen 3 never shuts off
When I had the charger I always plugged it into the cart first then the wall AC. Just the way I always done it for some reason. Never tried it any other way.
It would hum for a few seconds (15-30 give or take) then kick on and start charging. It would charge up to, IIRC, 62-63v with the "power on" and "charging" light illuminated, then float at 57-58v with only the "charged" light illuminated. I had it always set to the US Battery mode so I don't know if that makes a difference or not. LukeL, PM me if I need to do anything to make this right. |
11-08-2018, 10:22 AM | #8 |
Gone Wild
Join Date: Jun 2017
Location: Savannah, GA
Posts: 6,539
|
Re: DPI gen 3 never shuts off
I can try the US battery mode. The strange thing is that it’s not shutting off. Would it shut off by morning for you?
Club Car DS driver’s club #59 |
11-08-2018, 10:29 AM | #9 |
Just Gone
Join Date: Sep 2015
Location: North Carolina
Posts: 3,549
|
Re: DPI gen 3 never shuts off
Yes, it would quit charging and be in float mode only "charged" light illuminated. Very low amperage (needle would be on 1 amp maybe) charging when i would go to disconnect.
Also, charger was ALWAYS disconnected from wall power when not being used to prevent any power surges or lightening strikes messing it up. |
11-08-2018, 10:33 AM | #10 |
Gone Wild
Join Date: Jun 2017
Location: Savannah, GA
Posts: 6,539
|
Re: DPI gen 3 never shuts off
This is very unusual. Maybe I should call them.
Club Car DS driver’s club #59 |
|
|
Similar Threads | ||||
Thread | Forum | |||
PDS run up to 80%, then shuts down to 10% | Electric EZGO | |||
91 EZGO shuts down | Gas EZGO | |||
1999 G16 Shuts Down | Gas Yamaha | |||
amp shuts off. ........ help please | Design Center | |||
txt goes than shuts down than it goes | Electric EZGO |