lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric EZGO
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV.



Post New Thread  Reply
 
Thread Tools Display Modes
Old 03-16-2019, 11:49 AM   #1
MUDSLINGER250
Getting Wild
 
Join Date: Aug 2011
Posts: 131
Default What now

So the plug came out of the rear end and drained the gear oil it's been running fine I didnt know the plug was gone until yesterday I cleaned all the mud off and found that. After the good washing off the cart was driving fine then the brakes locked up. So I tinkered with the brake plug made sure no water was in it. Then I winched it to its usual parking spot where it charges. After a few minutes I thought let's try it got on it and it drove normal I went all over the yard slow and fast no problems so I parked it to charge and left it. Got on it this morning it took right off batteries 100% charge running great pull outta the yard 80 yards from parked spot brake locks up while driving. Flipped switch to tow mode pushed it back in the yard took the brake off cleaned it inside and out with electric motor cleaner put it all back together wont budge an inch. When you swap #3 plug to 1 the brake releases so cart will move. I also checked the run plug under the dash it had a tiny bit of water in it so I hit it with cable cleaner. Only thing I noticed when brake was apart was the plastic electromagnet housing had a tiny gap where it was put together from factory i dunno if water may have gotten in it and been sitting. When I loosened brake to take off water ran out. When the key is turned on it makes all sounds like brake disengages and solenoid click. I have pulled twisted and flicked every wire and joint I see I have mashed and tapped both pedals. Anybody have the magic answer?
MUDSLINGER250 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 03-16-2019, 07:54 PM   #2
MUDSLINGER250
Getting Wild
 
Join Date: Aug 2011
Posts: 131
Default Re: What now

This is a 2014 rxv brand new batteries.
MUDSLINGER250 is offline   Reply With Quote
Old 03-17-2019, 08:54 AM   #3
MUDSLINGER250
Getting Wild
 
Join Date: Aug 2011
Posts: 131
Default Re: What now

Cart runs like a brand new one this morning so who knows. Maybe moisture got into something.
MUDSLINGER250 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric EZGO


Thread Tools
Display Modes



All times are GMT -5. The time now is 06:52 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.