1994 Ezgo Textron

HEATH8BALL · 06-08-2009, 02:21 PM

This is just a shot in the dark but worth a try…

I just was given second ezgo cart, a 1994 Textron electric golf cart that does not run. Any help as to where to start. one of my biggest concerns is I am only getting 24 volt when checking with a volt meter...next is when checking the solenoid, the pos. prong is getting 24 volt but when turning the key or pushing the gas petal nothing is coming from any other prong... (Nothing...no volts) might be doing this wrong but reading on the internet that is what they said to do.

I can not compare it to my other ezgo cart 2004 (I think) and 1994

HEATH8BALL · 06-18-2009, 10:41 AM

1994 electric Ezgo txt

OK, I have run a few test, I had to change the solenoid...it was bad. Now I am getting 36 volts all the way to the motor, but still nothing. I have run the test on the motor, and the motor runs...now I am stuck. Any suggestions

Does anyone have a drawing on the small wires?

DR1989 · 06-18-2009, 11:59 AM

Welcome to bgw
What is your total voltage across the pack?

dock98 · 06-18-2009, 12:23 PM

welcome to BGW.

pggroves · 06-18-2009, 01:40 PM

Is the 94 a Marathon or a Medalist?

HEATH8BALL · 06-22-2009, 08:40 AM

Is the 94 a Marathon or a Medalist? = not sure...??? All it has is EZGO Textron

As of Sunday total volts are 31-32

Question: next to the solenoid on top of the throttle switch...there are 3 terminals... I have a wire on the left and right one…no wire in the middle. Is that the way it should be…???? Plus I have another one in the front with no wire. It is right by the hot wire going to the reverse warning device. The other two wires here are white and black they go back to the control module.

pggroves · 06-22-2009, 10:49 AM

BATTERY BAY:

2 packs of three on either side = Marathon
6 batteries in center = Medalist

HEATH8BALL · 06-22-2009, 12:27 PM

it does 2 packs of three on either side = Marathon

pggroves · 06-22-2009, 12:44 PM

Use this to trace and confirm all wiring! Your batteries are dead too!

HEATH8BALL · 06-23-2009, 11:21 AM

We will buy new batteries...but we want to see it run first...i see some of the wires are not in the same place as this drawing...again when hooking up just the motor direct it does turn...is there some test I can do to test the micro switches

06-08-2009, 02:21 PM	#1
HEATH8BALL Not Yet Wild Join Date: Jun 2009 Posts: 11	1994 Ezgo Textron This is just a shot in the dark but worth a try… I just was given second ezgo cart, a 1994 Textron electric golf cart that does not run. Any help as to where to start. one of my biggest concerns is I am only getting 24 volt when checking with a volt meter...next is when checking the solenoid, the pos. prong is getting 24 volt but when turning the key or pushing the gas petal nothing is coming from any other prong... (Nothing...no volts) might be doing this wrong but reading on the internet that is what they said to do. I can not compare it to my other ezgo cart 2004 (I think) and 1994
HEATH8BALL Not Yet Wild Join Date: Jun 2009 Posts: 11

06-18-2009, 10:41 AM	#2
HEATH8BALL Not Yet Wild Join Date: Jun 2009 Posts: 11	Re: 1994 Ezgo TXT 1994 electric Ezgo txt OK, I have run a few test, I had to change the solenoid...it was bad. Now I am getting 36 volts all the way to the motor, but still nothing. I have run the test on the motor, and the motor runs...now I am stuck. Any suggestions Does anyone have a drawing on the small wires?
HEATH8BALL Not Yet Wild Join Date: Jun 2009 Posts: 11

06-18-2009, 11:59 AM	#3
DR1989 Not Yet Wild Join Date: Feb 2009 Location: winnsboro sc Posts: 70	Re: 1994 Ezgo Textron Welcome to bgw What is your total voltage across the pack?

06-18-2009, 12:23 PM	#4
dock98 doin it in the desert Join Date: Dec 2008 Location: Sonora Desert,Az Posts: 5,603	Re: 1994 Ezgo Textron welcome to BGW.

06-18-2009, 01:40 PM	#5
pggroves steeplejack x Join Date: Jan 2007 Location: Republic of Texas Posts: 3,382	Re: 1994 Ezgo Textron Is the 94 a Marathon or a Medalist?

Today
BGW	Sponsored Links __________________ This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum

06-22-2009, 08:40 AM	#6
HEATH8BALL Not Yet Wild Join Date: Jun 2009 Posts: 11	Re: 1994 Ezgo Textron Is the 94 a Marathon or a Medalist? = not sure...??? All it has is EZGO Textron As of Sunday total volts are 31-32 Question: next to the solenoid on top of the throttle switch...there are 3 terminals... I have a wire on the left and right one…no wire in the middle. Is that the way it should be…???? Plus I have another one in the front with no wire. It is right by the hot wire going to the reverse warning device. The other two wires here are white and black they go back to the control module.
HEATH8BALL Not Yet Wild Join Date: Jun 2009 Posts: 11

06-22-2009, 10:49 AM	#7
pggroves steeplejack x Join Date: Jan 2007 Location: Republic of Texas Posts: 3,382	Re: 1994 Ezgo Textron BATTERY BAY: 2 packs of three on either side = Marathon 6 batteries in center = Medalist

06-22-2009, 12:27 PM	#8
HEATH8BALL Not Yet Wild Join Date: Jun 2009 Posts: 11	Re: 1994 Ezgo Textron it does 2 packs of three on either side = Marathon
HEATH8BALL Not Yet Wild Join Date: Jun 2009 Posts: 11

06-23-2009, 11:21 AM	#10
HEATH8BALL Not Yet Wild Join Date: Jun 2009 Posts: 11	Re: 1994 Ezgo Textron We will buy new batteries...but we want to see it run first...i see some of the wires are not in the same place as this drawing...again when hooking up just the motor direct it does turn...is there some test I can do to test the micro switches
HEATH8BALL Not Yet Wild Join Date: Jun 2009 Posts: 11

Similar Threads
Thread	Forum
1994 Ezgo Medalist	Electric EZGO
EZgo Textron 26568-g01	Electric EZGO
ezgo textron lift	Electric EZGO
1997 EZGO Textron Wiring for Lights	Electric EZGO