|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
10-06-2009, 11:26 AM | #1 |
Getting Wild
Join Date: Jul 2009
Location: Arlington
Posts: 127
|
Electric Ezgo Battery Charge (Batteries or controller?)
I have an older ezgo (pic attached) and its acting up. Last week I could drive it around like the batteries were decent it would go up little hills and such, and this week it wont even go up my driveway after an overnight charge! (My drive way is just a slight incline, should be NO problem)..
The owner i got it from before said that it used to be able to pull his f350 around but something was wrong with it (Not the batteries, he replaced those and said it didn't fix the problem) so i bought it for 150 and like I said, it just is getting worse and now cant make it up my driveway... Could it be the controller is going bad? How can i find out? Thanks guys |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-07-2009, 02:08 PM | #2 |
Not Yet Wild
Join Date: Oct 2009
Location: Virginia Beach, VA
Posts: 62
|
Re: Electric Ezgo Battery Charge (Batteries or controller?)
did you try following the diagnostic tips under EZGO of this forum. Its the second one down. Very usefull. What is your over all voltage reading accross the batteries? If its low, then check the voltage drop accross each battery, if those are good then clean your connections ect ect.
|
10-09-2009, 02:26 PM | #3 |
Getting Wild
Join Date: Jul 2009
Location: Arlington
Posts: 127
|
Re: Electric Ezgo Battery Charge (Batteries or controller?)
Hmm I couldn't Find that.. Would you mind sending a link?
|
10-09-2009, 02:58 PM | #4 | |
Stay thirsty my friends!
Join Date: Jan 2007
Location: Suburban Chicago
Posts: 24,291
|
Re: Electric Ezgo Battery Charge (Batteries or controller?)
Quote:
|
|
10-09-2009, 03:19 PM | #5 |
Getting Wild
Join Date: Jul 2009
Location: Arlington
Posts: 127
|
Re: Electric Ezgo Battery Charge (Batteries or controller?)
Amazingly enough I have been told its a controller, but I have attached a photo of it just incase someone needs to correct me
I just tried to figure out how it is wired and I had to walk away. When I followed the wires from the battery the + Went to the solenoid, and the negitive went to the controller.. from there I am lost. LOL Also, I don't believe it is the batteries becasue I swapped the 2 of the 6volters with my new charged up 12v Deep cell and it still didnt go unless i pushed it. Any Ideas? Could the controller be slowly going bad? Thanks so much guys |
10-09-2009, 03:46 PM | #6 |
Getting Wild
Join Date: Jul 2009
Location: Arlington
Posts: 127
|
Re: Electric Ezgo Battery Charge (Batteries or controller?)
Ahh Please help! What could be broken that allows it to go, but not go like it should. It will move with a push, or on flat ground. It is like the batteries have a very weak charge or something, But they don't.. Controller? Motor? Ugh whats the problem!
|
10-09-2009, 10:05 PM | #7 |
Not Yet Wild
Join Date: Oct 2009
Location: Virginia Beach, VA
Posts: 62
|
Re: Electric Ezgo Battery Charge (Batteries or controller?)
http://www.buggiesgonewild.com/elect...agnostics.html
here is the link |
10-09-2009, 10:12 PM | #8 |
Not Yet Wild
Join Date: Oct 2009
Location: Virginia Beach, VA
Posts: 62
|
Re: Electric Ezgo Battery Charge (Batteries or controller?)
what is your total voltage accross the battery bank? How much voltage at the controller? Are the connections clean? what is the voltage across each battery? Is there a battery in backwards? The batteries are to be wired in series with each other IE: + - + - + - + - + - + - each + - should be above 6Volts and reading the first + and the last - should be more than 36V All connections need to be very clean and tight.
|
10-09-2009, 10:53 PM | #9 | |
Gone Wild
Join Date: Nov 2008
Location: MI, West Coast
Posts: 235
|
Re: Electric Ezgo Battery Charge (Batteries or controller?)
Quote:
Last edited by iaefebs; 10-09-2009 at 11:02 PM.. Reason: added information |
|
10-10-2009, 12:58 AM | #10 | |
Not Yet Wild
Join Date: Oct 2009
Location: Virginia Beach, VA
Posts: 62
|
Re: Electric Ezgo Battery Charge (Batteries or controller?)
Quote:
Had a chance to read some voltages yet? |
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Changed batteries/batteries won't charge | Electric Club Car | |||
EZGO Textron 36 Volt Battery Charger will not charge | Electric EZGO | |||
ezgo starter generator wont charge battery but will turn motor | Gas EZGO | |||
Club Car battery charger won't charge new batteries | Electric golf carts | |||
Electric EZGO Won't Charge | Electric EZGO |