|
|||||||
| Notices | ||
|
| Electric EZGO Electric EZGO Marathon, Medalist, TXT and RXV. |
|
  |
|
|
Thread Tools | Search this Thread | Display Modes |
|
|||||||
| Notices | ||
|
| Electric EZGO Electric EZGO Marathon, Medalist, TXT and RXV. |
|
|
| |
|
|
Thread Tools | Search this Thread | Display Modes |
03-08-2008, 04:05 PM
|
#1 |
|
Not Yet Wild
Join Date: Mar 2008
Posts: 8
|
surging problem
i recently swapped out the motor in my ez go golf cart and since then while riding i feel it sort of surging on the top end. it was a used motor. does that problem sound like the motor or sme other component? any ideas??
|
|
|
|
|
|
|
03-08-2008, 04:08 PM
|
#2 |
|
Gone Wild
Join Date: Jun 2007
Posts: 346
|
Re: surging problem
An electric motor is doing this?
|
|
|
|
|
03-08-2008, 11:38 PM
|
#3 |
|
Not Yet Wild
Join Date: Mar 2008
Posts: 8
|
Re: surging problem
yes but it wasnt doing it in te other cart i took the motor out of. once it gets to top speed it, for lack of another term, surges. does it have some sort of high low switch? any ideas are appreciated
|
|
|
|
|
03-08-2008, 11:40 PM
|
#4 |
|
GhEtTo PrAnKsTeR
Join Date: Jun 2007
Location: Kaufman, Texas
Posts: 3,098
|
Re: surging problem
No it doesn't have a high/low switch...sounds almost like a pot box issue.
|
|
Golf Cars | Lifted Golf Carts | Electric Golf Carts
Custom EZGO | B&S V-Twin | All Sports Long Travel Lift | 8:1 Gears | 22" Titan AT489's  | |  |  |  |  |  | 
|
|
|
|
|
|
03-09-2008, 07:01 PM
|
#5 |
|
Not Yet Wild
Join Date: Mar 2008
Posts: 8
|
Re: surging problem
what is a pot box? what does it do?
|
|
|
|
|
03-09-2008, 07:02 PM
|
#6 |
|
Not Yet Wild
Join Date: Mar 2008
Posts: 8
|
Re: surging problem
and how should i diagnose it?
|
|
|
|
|
03-09-2008, 07:41 PM
|
#7 |
|
GhEtTo PrAnKsTeR
Join Date: Jun 2007
Location: Kaufman, Texas
Posts: 3,098
|
Re: surging problem
A pot box is the throttle...it is sorts like or variable resistor. E-z-go's throttle runs from 0 ohm (0% throttle) to 5k ohm (100% throttle) You will have to get a volt/ohm meter to check it.
|
|
Golf Cars | Lifted Golf Carts | Electric Golf Carts
Custom EZGO | B&S V-Twin | All Sports Long Travel Lift | 8:1 Gears | 22" Titan AT489's | | | | | | |
|
|
|
|
|
|
03-10-2008, 07:33 PM
|
#8 |
|
Not Yet Wild
Join Date: Mar 2008
Posts: 8
|
Re: surging problem
well it is a 94 model. where would the pot box be located? i have an ohm meter.
|
|
|
|
|
03-10-2008, 08:21 PM
|
#9 |
|
Two Cheeks Sliding
Join Date: Jan 2007
Location: Suburban Chicago
Posts: 1,949
|
Re: surging problem
Follow the accelerator linkage under the cart. When you press the gas, you are moving the potentiometer.
|
|
|
|
03-11-2008, 08:03 PM
|
#10 |
|
Not Yet Wild
Join Date: Mar 2008
Posts: 8
|
Re: surging problem
i think i found it. if its the box bhind the switch. yes the one the linkage is hooked to. well i have a three wheel model the same year as this one so i will try swapping them
|
|
|
|
|
| Thread Tools | Search this Thread |
| Display Modes | |
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| Carb Problem | Gas Club Car | |||
| Go Problem | Electric EZGO | |||
| Electrical Problem | Electric Club Car | |||
| G1 up hill problem... | Gas Yamaha | |||
| need a help with no go problem | Electric Club Car | |||
Linear Mode
