|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
09-22-2010, 03:57 PM | #1 |
Not Yet Wild
Join Date: Sep 2010
Posts: 6
|
1997 ezgo electric golf cart
my cart had been running ok then when I went to accelarate it was as if it would not go into gear. It has a sound of like a plastic gear is not engaging to turn the wheels. Can anyone advise me on what I need to do? This is not a battery problem, they are charged. thanks
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-22-2010, 04:08 PM | #2 |
......................
Join Date: Apr 2009
Location: FT Lauderdale FL.
Posts: 16,416
|
Re: 1997 ezgo electric golf cart
Welcome to BGW
can you listen closer to the noise and figure out where it is coming from, it sounds like a striped brake drum on the read axle? |
09-22-2010, 04:30 PM | #3 |
Not Yet Wild
Join Date: Sep 2010
Posts: 6
|
Re: 1997 ezgo electric golf cart
sounds more like from the middle of the axile, but I am courious about your response on how that would have anything to do with it not engaging, the brakes are not locked up, thanks for the reply.
|
09-22-2010, 05:01 PM | #4 |
......................
Join Date: Apr 2009
Location: FT Lauderdale FL.
Posts: 16,416
|
Re: 1997 ezgo electric golf cart
Ezgo's are known for striping out the brake drum,--the axle has a spline on it that the brake drum fits on to drive the the cart, and it strips out, an easy way to check it is to, jack up the cart put it on jack stands, pull the wheel off and remove the center cap so you can see the castle nut that holds the drum on the axle,have some one ut there foot on the brake and then push the go pedal just a little, while you look at that nut and see if it is spinning, and the drum is not.
But if you think it is coming from the center where the motor hook up to the rear end, you need to pull the motor off and see whats up in there O and Welcome to BGW |
09-23-2010, 08:32 AM | #5 |
Gone Wild
Join Date: Nov 2008
Location: Montgomery, AL
Posts: 1,463
|
Re: 1997 ezgo electric golf cart
I have seen the collar from the motor to input shaft of diff strip, but its very uncommon.
I would have 2 agree with RIB. It sounds like you have a stripped hub/brake drum. If you replace them make sure you torque that castle nut to atleast 80 ft lbs. Also do not back off the nut to put in cotter pin, keep tighting until the pin goes in. |
09-23-2010, 08:39 PM | #6 |
Not Yet Wild
Join Date: Sep 2010
Posts: 6
|
Re: 1997 ezgo electric golf cart
where is the spline located?
|
09-23-2010, 09:21 PM | #7 |
......................
Join Date: Apr 2009
Location: FT Lauderdale FL.
Posts: 16,416
|
Re: 1997 ezgo electric golf cart
the spline is on the end of the axle, and the in side of the drum, where the drum slides on the axle, it's hard to see in the pic but rite there on the end of the axle.--at the bottom of the pic
|
09-24-2010, 10:23 AM | #8 |
Not Yet Wild
Join Date: Sep 2010
Posts: 6
|
Re: 1997 ezgo electric golf cart
the spline on the right side axle is worn out on the hub, the other is ok, however the noise that I hear is coming from the motor area. The rear axle will turn (both sides) when i run the motor, however, it is not engaged because I can hold the axle and it just spins. and suggestions where to start on this? thanks for your help.
|
09-24-2010, 08:06 PM | #9 |
Not Yet Wild
Join Date: Sep 2010
Posts: 6
|
Re: 1997 ezgo electric golf cart
RIB......thanks for the help, I'm back up and running the fairways. Your info was very helpful. Thanks again.
|
09-24-2010, 08:48 PM | #10 |
.....He, not ME
Join Date: Sep 2010
Location: Spring Hill, FL
Posts: 390
|
Re: 1997 ezgo electric golf cart
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
ezgo electric golf cart | Electric EZGO | |||
1995 ezgo electric golf cart | Electric EZGO | |||
1995 electric ezgo golf cart | Electric EZGO | |||
1997 ezgo txt electric cart quit running need help | Electric EZGO |