Towing and thermal shutdown

alexisp · 05-18-2008, 11:42 PM

Hi Everyone,

I have a 2002 EZ-Go pds cart. I use it to pull a high weed mower. It pulls great but will only run for about 30 minutes and then it shuts down. If I let is sit for an hour or two, I can run it again for 30 minutes then it shuts down. I put new cables in it, batteries are new and good, new solendoid.

Controller? Lower gear ratio? What would help?

roady89 · 05-19-2008, 08:22 AM

Did you upgrade to 4 gauge cables? 4 gauge cables and a high amp controller.....maybe a low speed torque motor will cure that problem.

The low speed torque motor alone should cure it....even a Higher Ratio gear set.

rusty · 05-19-2008, 05:29 PM

Welcome alexisp.................

05-18-2008, 11:42 PM	#1
alexisp Not Yet Wild Join Date: May 2008 Posts: 1	Towing and thermal shutdown Hi Everyone, I have a 2002 EZ-Go pds cart. I use it to pull a high weed mower. It pulls great but will only run for about 30 minutes and then it shuts down. If I let is sit for an hour or two, I can run it again for 30 minutes then it shuts down. I put new cables in it, batteries are new and good, new solendoid. Controller? Lower gear ratio? What would help?
alexisp Not Yet Wild Join Date: May 2008 Posts: 1

05-19-2008, 08:22 AM	#2
roady89 nimda Join Date: Jun 2007 Posts: 13,022	Re: Towing and thermal shutdown Did you upgrade to 4 gauge cables? 4 gauge cables and a high amp controller.....maybe a low speed torque motor will cure that problem. The low speed torque motor alone should cure it....even a Higher Ratio gear set.
roady89 nimda Join Date: Jun 2007 Posts: 13,022

05-19-2008, 05:29 PM	#3
rusty Golf Cart Photographer Join Date: Jan 2007 Location: Wichita Falls Texas - My Ride 2010 Club Car Posts: 6,236	Re: Towing and thermal shutdown Welcome alexisp.................

Today
BGW	Sponsored Links __________________ This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum