|
Electric golf carts Harley Davidson, Melex, Pargo, Taylor-Dunn and other Misc. Carts. |
|
Thread Tools | Display Modes |
01-19-2011, 01:43 PM | #1 |
Not Yet Wild
Join Date: Jan 2011
Posts: 5
|
94 electric ez go "chugs"
Only way I can describe it is a car running out of gas. Battteries are fully charged. When you push pedal the cart "chugs" it will go forward and back, (barely) but in a chugging motion like its not getting all the juice it needs. Kids were riding it fine, parked for a minute to pull in garage and the cart started doing this. Thanks for the help and a great site.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
01-19-2011, 01:59 PM | #2 |
Stay thirsty my friends!
Join Date: Jan 2007
Location: Suburban Chicago
Posts: 24,291
|
Re: 94 electric ez go "chugs"
Welcome to BGW!
Every sparky problem starts with voltage. We need you pack voltage, and individual battery voltages, both at rest and while the cart is trying to run. One bad cell can bring the pack down. Also, does the cart freewheel easily by hand? Finally, is this a controller or resistor cart? |
01-19-2011, 02:38 PM | #3 |
Not Yet Wild
Join Date: Jan 2011
Posts: 5
|
Re: 94 electric ez go "chugs"
I dont have a lot of knowledge on this stuff but Im learning. 6 batts. at 6 volts makes it a 36 v system. I can push it freely. I believe it is a controller system....has the black box next to the batteries that run to the motor on the axle.
Rest voltage-6.2-6.4 Attempt to move-down to 5.9 most of time did see a 5.7 not that means anything but all six batteries were new in July 10 Thanks for helping |
01-19-2011, 02:43 PM | #4 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,418
|
Re: 94 electric ez go "chugs"
6.3 x 6 = 37.8 volts Fully charged is 38.4 36.1 is empty .... Is there any clicking noise when it is doing this chugging? IF not might just be a loose battery cable connection? or a burnt up F&R direction switch? Does it do it in F&R? have you checked all cable connections? Tug on them to see they are solid?
|
01-19-2011, 03:13 PM | #5 |
Not Yet Wild
Join Date: Jan 2011
Posts: 5
|
Re: 94 electric ez go "chugs"
Yes I checked the cables they all seem tight. It does it in foreward and reverse. I will check the resting votage again. Do I need to disconnect the system to do this? I previously checked each battery but did not disconnect anything. I did not hear any clicking. Will go through connections again. Thanks
|
01-19-2011, 03:16 PM | #6 |
Not Yet Wild
Join Date: Jan 2011
Posts: 5
|
Re: 94 electric ez go "chugs"
There is a single click from the controller box, then the rear end motor starts its thumping sound like it wants to go but is not gettting what it wants for juice. I
|
01-19-2011, 03:17 PM | #7 |
Not Yet Wild
Join Date: Jan 2011
Posts: 5
|
Re: 94 electric ez go "chugs"
The cart just bucks at this point no matter F/R
|
04-12-2018, 09:22 PM | #8 |
Gone Wild
Join Date: Jun 2012
Location: East Tx
Posts: 323
|
Re: 94 electric ez go "chugs"
Did you ever figure out what was wrong? My 86 Marathon is doing the same thing.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
4 wheel electric cushman truckster "free to a good home" | Golf Carts and Parts | |||
Electric Golf Cart "running out of gas" | Electric golf carts | |||
"waterproofing" electric cart | Lifted Golf Carts | |||
EZ Go Electric "hops" and slows down and stops running | Electric EZGO |