11-15-2015, 06:28 PM | #1 |
Not Yet Wild
Join Date: Nov 2015
Posts: 16
|
No spark on 2000 year cart
2000 club car 150 + psi got it home drove it around yard then no spark if you let the starter run for a couple of minutes it does start and run ?????? checked all the switches ok what else to check???
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
11-15-2015, 06:37 PM | #2 |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,928
|
Re: No spark on 2000 year cart
A common problem for a "no spark" scenario, is a failing rev limiter!
On the lower front of the engine, you'll see a little box (rev limiter) with 2 mounting bolts, left and right, there is a ground wire tied to the left (pass side) mounting bolt, remove the bolt, remove the eye loop from the bolt, reinstall the bolt, and tape up the eye loop! As long as your governor hasn't been tampered with, you should be safe running it without the rev limiter! (as long as you don't go down a long, steep hill at full throttle) |
11-15-2015, 07:59 PM | #3 |
Not Yet Wild
Join Date: Nov 2015
Posts: 16
|
Re: No spark on 2000 year cart
That did not work i dont think this cart has been messed with it was in a shed and been sitting but the key switch is bad and they put a toggle switch on it goes to jumpers on the sol. but it did run got a new key switch on order it has 800 hr on it
|
11-15-2015, 08:54 PM | #4 |
Not Yet Wild
Join Date: Nov 2015
Posts: 16
|
Re: No spark on 2000 year cart
why is this not showing in new posts ???
|
11-16-2015, 07:39 AM | #5 |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,928
|
Re: No spark on 2000 year cart
Have you looked behind the dash at the original key switch wiring?
It may be not connecting properly or grounding out... Here's a key switch wiring diagram when yours come in! Key Switch wiring.jpg |
11-16-2015, 09:07 PM | #6 |
Not Yet Wild
Join Date: Nov 2015
Posts: 16
|
Re: No spark on 2000 year cart
i took the rev box out i have spark but what i think is wrong the wire to the coil is not connected to any thing and i have spark i did a ohm check coil is good but rev box is bad
|
11-16-2015, 09:13 PM | #7 |
Not Yet Wild
Join Date: Nov 2015
Posts: 16
|
Re: No spark on 2000 year cart
I got a service/ repair manual that shows all the wire diagram and all seems ok checked all micro switches im thinking rev box and carb ????
|
11-16-2015, 09:26 PM | #8 |
Not Yet Wild
Join Date: Nov 2015
Posts: 16
|
Re: No spark on 2000 year cart
just looked at price on rev box can i just by pass
|
11-16-2015, 09:50 PM | #9 |
Getting Wild
Join Date: Jan 2015
Location: s e mo
Posts: 120
|
Re: No spark on 2000 year cart
unhook ground and tape it
|
11-17-2015, 06:18 AM | #10 |
Not Yet Wild
Join Date: Nov 2015
Posts: 16
|
Re: No spark on 2000 year cart
If I just unhook ground still no spark took it all the way out and now i have spark will it be ok with the coil wire unhooked also
|
|
|
Similar Threads | ||||
Thread | Forum | |||
My 2000 CC DS lost spark | Gas Club Car | |||
2000 TXT Has No Spark | Gas EZGO | |||
2000 Club Car Gas No spark! | Gas Club Car | |||
2000 Club Car Gas No spark! | Gas EZGO |