lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car
Gas Club Car Gas DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 01-16-2016, 12:36 PM   #1
Not Yet Wild
 
Join Date: Feb 2007
Posts: 4
Default Good elect but slow to turn over

I have a 95 gasser that's been having an issue turning over. It seems to have a few "dead spots" and will eventually get to where it will spin and turn over.
I just replaced the battery because it wouldn't hold a charge. I replaced the micro switches, drive belt, and starter brushes a year ago. The brushes are still good.
It just has a hard time turning over...tries....moves a bit...tries again..and then will finally start to spin.

Could the starter/generator just be worn out?...maybe a flat spot in the windings?
I checked the voltage and its all good when at idle and at a higher speed.
wjftsf is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 01-16-2016, 01:12 PM   #2
Gone Wild
 
ironmonkey17's Avatar
Mixed Breed
 
Join Date: Apr 2014
Location: Ohio
Posts: 868
Default Re: Good elect but slow to turn over

make sure your valves are adj. correctly (.005) if not you'll have compression issues, make sure battery is good, I had a battery that showed good on a meter but under load it was no good, auto parts store will do a load test on it for free. I would check the battery first, start out cheap then work your way up.
ironmonkey17 is offline   Reply With Quote
Unread 01-16-2016, 01:56 PM   #3
Not Yet Wild
 
Join Date: Feb 2007
Posts: 4
Default Re: Good elect but slow to turn over

I just bought a new battery last night and then checked everything on the meter...all showing charging correctly.
I did tighten the S/G belt and it seemed to help some but there's still like a "flat spot" before it turns over quickly.
Now it seems to not have the same power it once did.
wjftsf is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
2006 PDS runs good then runs slow Electric EZGO
runs good slow until fast then it cuts off :-/ Electric EZGO
For those with not to good slow speed and a backfire occasionally. Gas Club Car
good pot box good batteries still only goes slow or cuts out Electric EZGO
Question on G1- Slow to turn over and run sometimes??? Gas Yamaha


All times are GMT -5. The time now is 09:13 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2018, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.