lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car
Gas Club Car Gas DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 07-04-2016, 03:24 PM   #1
Not Yet Wild
 
Join Date: Jul 2016
Posts: 9
Question Club car precedent 2005 starting problem

I bought a second hand 2005 precedent club car. It a has intermittent starting problem. I opened the carburettor and gave it a good clean up, changed the fuel pump but cart still start and losses it and not start at all. I took out the GCOR and tested the continuity on both the white and black wires and resistance it gives me 0.1 ohms. Turned the arm hole with a screw driver continuity is fine and ohm reading 0.1 as well not sure what to check next.
phoddy is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 07-04-2016, 05:56 PM   #2
Gone Wild
 
Golf cart guy's Avatar
 
Join Date: May 2015
Location: Central Florida
Posts: 1,688
Default Re: Club car precedent 2005 starting problem

when it doesn't start you just need to find out what it missing:
Spark
Fuel
Air
or Compression
Golf cart guy is offline   Reply With Quote
Unread 07-05-2016, 01:12 AM   #3
Not Yet Wild
 
Join Date: Jul 2016
Posts: 9
Default Re: Club car precedent 2005 starting problem

I had my mechanic check the fuel supply. We made a gravity feed pipe to supply fuel and the car ran very well. Then we thought it could be the fuel pump which caused me some few bucks. But the cart continues to br-br-br. Then it doesn't start.
phoddy is offline   Reply With Quote
Unread 07-06-2016, 07:39 PM   #4
Gone Wild
 
Golf cart guy's Avatar
 
Join Date: May 2015
Location: Central Florida
Posts: 1,688
Default Re: Club car precedent 2005 starting problem

So when it doesn't start what are you missing?
Golf cart guy is offline   Reply With Quote
Unread 07-11-2016, 02:06 AM   #5
Not Yet Wild
 
Join Date: Jul 2016
Posts: 9
Default Re: Club car precedent 2005 starting problem

I am still busy with fault finding. So far it looks like my battery might be on its way. when I push the gas pedal it drops the voltage to below 11.8. I will change the battery this afternoon.

But I have also noticed lot of grass in the fan housing. I am hoping that is not also acting as a braking system there. Not sure if I have to remove the exhaust pipe to get there because of the limited space.
phoddy is offline   Reply With Quote
Unread 07-11-2016, 08:39 PM   #6
Gone Wild
 
Golf cart guy's Avatar
 
Join Date: May 2015
Location: Central Florida
Posts: 1,688
Default Re: Club car precedent 2005 starting problem

Motor will crank with 11.8 volts. This is a very simple motor to figure out the problem
Golf cart guy is offline   Reply With Quote
Unread 07-13-2016, 01:20 PM   #7
Not Yet Wild
 
Join Date: Jul 2016
Posts: 9
Default Re: Club car precedent 2005 starting problem

Guys while I was busy with the fault finding I noticed some debris in the tank. I drained the tank this afternoon. Will leave for the night to dry out. I could tell from opening the suction pipe that the pipe before the pump has been dry for some time. I will strip and clean the pump and carburettor tomorrow in case some dirt has already accumulated in there.

Will keep you posted.
phoddy is offline   Reply With Quote
Unread 07-18-2016, 12:47 AM   #8
Not Yet Wild
 
Join Date: Jul 2016
Posts: 9
Default Re: Club car precedent 2005 starting problem

Still sitting with fuel suction issue. The pump is not pulling the fuel. I will check the oil level in the crankcase.
phoddy is offline   Reply With Quote
Unread 07-18-2016, 12:00 PM   #9
Not Yet Wild
 
Join Date: Jul 2016
Posts: 9
Thumbs up Re: Club car precedent 2005 starting problem

Problem solved. I am up and running. Apart from the dirty system during the cleaning my mechanic packed the pump wrongly. There are 2 slots on the pump's base and the middle section always make sure the are in line when assembling the pump.

This was a costly fault finding but no regrets thus gave me an opportunity to learn "my boy".
phoddy is offline   Reply With Quote
Unread 08-15-2016, 08:02 AM   #10
Not Yet Wild
 
Join Date: Jul 2016
Posts: 9
Default Re: Club car precedent 2005 starting problem

Problem solved. It was the ignition Coil. Replaced it this weekend and all is good no more intermittent running.
phoddy is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
2005 Precedent battery replacement and overflow problem Electric Club Car
2005 CC Precedent Steering Problem Electric Club Car
04 Precedent starting problem Gas Club Car
2005 precedent mcor problem Electric Club Car
97 Gas Club Car Starting/RPM? Problem Gas Club Car


All times are GMT -5. The time now is 09:43 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2019, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.