![]() |
|
Gas Club Car Gas DS, and Precedent golf cars |
![]() ![]() |
Thread Tools | Display Modes |
![]() | #1 |
Not Yet Wild Join Date: Jun 2010
Posts: 14
| ![]() The main seal on my CC was damaged when the fuel pump failed and diluted the oil with gas(back thru the vacuum tube).After I discovered this-it was too late and the seal was leaking-badly. My plan is to put 3oz of Motorkote All Seal in the crankcase. At this point I really don't have much to lose but I'm certainly open to suggestions. Also-with 130 psi of compression,I really don't want to pull the engine and replace the seal. I'm open to all advice.Thanks!! |
![]() | ![]() |
![]() | |
![]() __________________ This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum | |
![]() | #2 |
Gone Wild ![]() Join Date: Oct 2009
Posts: 460
| ![]() What kind of oil are you using. |
![]() | ![]() |
![]() | #3 |
Not Yet Wild Join Date: Jun 2010
Posts: 14
| ![]() 10 w 30 |
![]() | ![]() |
![]() | #4 |
Gone Wild ![]() Join Date: Oct 2009
Posts: 460
| ![]() That's okay, I have heard that synthetic oil will cause it to leak. Synthetic is okay if you have always used it. |
![]() | ![]() |
![]() | #5 |
Gone Wild ![]() Join Date: Mar 2015 Location: Central mn
Posts: 674
| ![]() Do you mean the crank oil seal or the crankcase gasket Either one are not that hard to replace if you pull the clutch |
![]() | ![]() |
![]() | #6 |
Not Yet Wild Join Date: Jun 2010
Posts: 14
| ![]() Crank oil seal |
![]() | ![]() |
![]() | #7 |
Gone Wild ![]() Join Date: Mar 2015 Location: Central mn
Posts: 674
| ![]() If you pull the clutch off you can replace the seal with the engine in the cart |
![]() | ![]() |
![]() | #8 |
Not Yet Wild Join Date: Jun 2010
Posts: 14
| ![]() I put 4oz of Motor Kote seal all in today(don't have a clutch puller). Will advise results soon. Thanks-Boss Hoss. |
![]() | ![]() |
![]() | #9 |
Not Yet Wild Join Date: Jun 2010
Posts: 14
| ![]() It was a failure and actually diluted the oil to make the leak worse. No dice to Motorkote seal all ![]() |
![]() | ![]() |
![]() | #10 |
Gone Wild ![]() Join Date: Mar 2015 Location: Central mn
Posts: 674
| ![]() I think if you jack up the passenger side of the cart, you should have enough room to take the clutch off. |
![]() | ![]() |
![]() |
|
Thread Tools | |
Display Modes | |
|
![]() | ||||
Thread | Forum | |||
81 Club Car Electric w/terrel axle seal leaking | Electric Club Car | |||
blown main seal | Gas EZGO | |||
oil leaking from driven clutch seal to the rear end | Gas EZGO | |||
1997 g16 leaking oil | Gas Yamaha | |||
1982 EZGO - Leaking pinion seal | Gas EZGO |