09-03-2017, 05:24 PM | #1 |
Not Yet Wild
Join Date: Sep 2017
Posts: 4
|
98 club car hesitates
Hi my name is Josh,
I have a 98 gas club car golf cart. When accelerating, an the engine starts to rev up. It dies or "hesitates" for a few seconds then picks back up like nothing happen????? Been stumped about this problem. Everything I've replaced on this is - carburetor - fuel pump -spark plug -coil pack - air filter -fuel filter -rev limiter -drive an generator belts |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-03-2017, 07:37 PM | #2 |
Getting Wild
Join Date: May 2017
Location: stl mo
Posts: 113
|
Re: 98 club car hesitates
Does it do this continuously, or just once?
I'd pull the fuel line of at carb and see if gas bubbles out. Sent from my Nexus 6P using Tapatalk |
09-03-2017, 07:51 PM | #3 |
Not Yet Wild
Join Date: Sep 2017
Posts: 4
|
Re: 98 club car hesitates
It does it once every time you take off from a start
|
09-06-2017, 12:44 PM | #4 |
Not Yet Wild
Join Date: Jul 2016
Location: Citrus Heights,CA
Posts: 9
|
Re: 98 club car hesitates
Check your ignition wires. As I have a 91 CCDS that was doing almost the same thing. I ended up replacing the carb and with multiple adjustments still getting the same out come. I just so happen to pull the rear cover off and found a red wire rubbing on the muffler causing the ignition to short out and stumble the whole time. Fixed the wire then zip tied it to the frame. All is good now runs like a champ. I wish I had taken a pic of it to show everyone. Cause this one got me good.
|
09-11-2017, 01:27 PM | #5 | |
Not Yet Wild
Join Date: Sep 2017
Posts: 4
|
Re: 98 club car hesitates
Quote:
"Dmaxowner" I have replaced the ignition coil. An it's only on take off when I have that issue. |
|
09-11-2017, 01:29 PM | #6 |
Not Yet Wild
Join Date: Sep 2017
Posts: 4
|
Re: 98 club car hesitates
An that should the carb jetting be on these?
|
09-12-2017, 12:57 PM | #7 |
Getting Wild
Join Date: May 2017
Location: stl mo
Posts: 113
|
Re: 98 club car hesitates
There aren't any carb adjustments on these carbs...
Is the stall predictable? Like about 10 seconds after first start? If so running the cart in maintenance mode while spraying starter fluid through the stall, should prove gas or not gas related issue with the cart. Sent from my Nexus 6P using Tapatalk |
10-10-2017, 12:38 PM | #8 |
Gone Wild
Join Date: Apr 2012
Location: s e mo
Posts: 169
|
Re: 98 club car hesitates
Stock is 80 or82. cart parts plus sells a 90 that works really well with k@ n.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Club Car Hesitates/stumbles badly cold | Gas Club Car | |||
92 gas club car hesitates | Gas Club Car | |||
Club Car Turf2 Ran great, now hesitates and sputters | Gas Club Car | |||
Club car hesitates before starting? | Gas Club Car | |||
01 48 volt club car hesitates | Electric Club Car |