98 club car hesitates

Josh132435

Hi my name is Josh,
I have a 98 gas club car golf cart.
When accelerating, an the engine starts to rev up. It dies or "hesitates" for a few seconds then picks back up like nothing happen????? Been stumped about this problem. Everything I've replaced on this is
- carburetor
- fuel pump
-spark plug
-coil pack
- air filter
-fuel filter
-rev limiter
-drive an generator belts

BGW

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum

jdgriner

Does it do this continuously, or just once?

I'd pull the fuel line of at carb and see if gas bubbles out.

Sent from my Nexus 6P using Tapatalk

Josh132435

It does it once every time you take off from a start

Dmaxowner

Check your ignition wires. As I have a 91 CCDS that was doing almost the same thing. I ended up replacing the carb and with multiple adjustments still getting the same out come. I just so happen to pull the rear cover off and found a red wire rubbing on the muffler causing the ignition to short out and stumble the whole time. Fixed the wire then zip tied it to the frame. All is good now runs like a champ. I wish I had taken a pic of it to show everyone. Cause this one got me good.

Josh132435

"Dmaxowner" I have replaced the ignition coil. An it's only on take off when I have that issue.

Josh132435

An that should the carb jetting be on these?

jdgriner

There aren't any carb adjustments on these carbs...

Is the stall predictable? Like about 10 seconds after first start?

If so running the cart in maintenance mode while spraying starter fluid through the stall, should prove gas or not gas related issue with the cart.

Sent from my Nexus 6P using Tapatalk

mckittrick.joe

Stock is 80 or82. cart parts plus sells a 90 that works really well with k@ n.