|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
01-25-2018, 07:37 AM | #1 |
Not Yet Wild
Join Date: Apr 2017
Posts: 8
|
Gas club car still stalls out
My 02 Gas club car keeps stalling out when it warms up'
If i choke it it starts and a few minutes later it does it again. I have replaced the battery, starter/generator, carb. and fuel pump, rectifier, all fuel lines and filter. The gas tank was removed and cleaned out. There is no water getting in carb. This is driving me "muckin futts". Any ideas? Please Thanks |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
01-25-2018, 07:59 AM | #2 |
Gone Wild
Join Date: Dec 2017
Location: Portsmouth, VA
Posts: 626
|
Re: Gas club car still stalls out
does it stall out on idle only or while running ??
maybe fuel air mixture is wrong ?? ie why it starts on choke |
01-25-2018, 03:13 PM | #3 |
Not Yet Wild
Join Date: Apr 2017
Posts: 8
|
Re: Gas club car still stalls out
It stalls out while it's running down the road.
|
01-25-2018, 04:32 PM | #4 |
Gone Wild
Join Date: Dec 2017
Location: Portsmouth, VA
Posts: 626
|
Re: Gas club car still stalls out
if it is running and stalls out as you say, i would guess it is not getting enough gas, or intermittent gas flow.
i would check fuel lines and filters, make sure there are no leaks, if you can see the fuel in the tube, are there any air bubbles or such in the line ?? make sure there are no KICKS are HARD bends in the line, smooth large radius bends and curves. if not maybe the fuel pump is dying, or not getting enough suction via the engine. think these are pulse pumps or vacuum pumps, with a line from engine to them to operate them. check that line as well. does not look like an electric pump. those are quick easy checks to do. |
01-26-2018, 07:54 AM | #5 |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,926
|
Re: Gas club car still stalls out
You might also want to check for spark when it stalls...
It's pretty common for the rev limiter, or coil to fail when the engine warms up! |
01-26-2018, 11:17 AM | #6 |
Gone Wild
Join Date: Dec 2017
Location: Portsmouth, VA
Posts: 626
|
Re: Gas club car still stalls out
|
01-28-2018, 02:16 PM | #7 |
Gone Wild
Join Date: May 2011
Posts: 195
|
Re: Gas club car still stalls out
Could be the coil. Sometimes a bad coil will fail when hot, resistance, etc, measures normal when cold.
|
01-28-2018, 02:48 PM | #8 |
Getting Wild
Join Date: Nov 2016
Location: michigan/georgia
Posts: 133
|
Re: Gas club car still stalls out
un plug wire by the dip stick that isolates coil and rev lim from key and micro switchs if it still stalls unhook ground{brown] wire from screw by rev limiter, if it still quits its the coil we sell org kawasaki coils , anything else is a waste of time putting in.i have seen the micro switchs go bad but work than open up under viberation also key switchs thats why you need it isolate them
|
01-28-2018, 02:52 PM | #9 |
Getting Wild
Join Date: Nov 2016
Location: michigan/georgia
Posts: 133
|
Re: Gas club car still stalls out
forgot on other thin check the vert hose off the carb if its pluged you get run and die most dont even have a hose but i seen a guy buy a new carb and hook it to a pluged hose ,worked just like an old carb!
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
99 gas club car revs then stalls | Gas Club Car | |||
2006 48V Club Car Stalls only going up hill | Electric Club Car | |||
93 Gas Club Car Stalls | Gas Club Car | |||
club car stalls going uphill | Gas Club Car | |||
99 club car starts and stalls...help | Gas Club Car |