|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
03-21-2010, 06:09 PM | #1 |
Not Yet Wild
Join Date: May 2009
Posts: 19
|
cc slow to rev since upgrade
I posted this yesterday but I can not find it? so I will do it again.
I have a 04 club car that I put the ccp exhaust on (love the tone) I also rejetted and kn filter I also put the timing key on. Now it revs up slow, if I hit the throttle hard, if you tip into it the engine will rev great and run fine. I cleaned the air jet no help. I also have messed with the mixture screw no help. This has all been done in the maint mode cause I have the body off still. (gettin painted) Does this have anything to do with it? anybody have any other ideas? Thanks Dan |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-22-2010, 03:17 PM | #2 |
Bad *** Speller!
Join Date: Oct 2009
Location: Columbus, Ohio
Posts: 1,338
|
Re: cc slow to rev since upgrade
sound like a carb issue. not saying the jet teh issue, but just a adjustment of the mixture screw on it . and im assuming were getting a good supply of fuel? meaning the pulse line is good and has a new fuel filter in it. but if it ran good nd this is all you messed with thats my assumtion.
|
03-22-2010, 05:05 PM | #3 |
Not Yet Wild
Join Date: May 2009
Posts: 19
|
Re: cc slow to rev since upgrade
It has to be getting good fuel supply because at higher rpm's it runs fine. So that would tell me I have good fuel. I talked to ccp today and they gave me a few things to check tonight. Will keep posted on outcome.
|
01-01-2011, 02:37 PM | #4 |
Not Yet Wild
Join Date: Apr 2010
Location: Auburn,AL
Posts: 55
|
Re: cc slow to rev since upgrade
Im having the same issue. Did you get it figured out?
|
01-01-2011, 03:19 PM | #5 |
Gone Wild
Join Date: Jul 2008
Location: Reddick IL
Posts: 11,220
|
Re: cc slow to rev since upgrade
Jones, that thread is 9 months old and
the op last post was 8 months ago I have a hunch you may need to clean the carb ((( a full knock down and clean all the bleed ports and passages))) these carbs don't have acceleration pumps and they need fuel to carry through the sudden opening of the throttle. |
01-01-2011, 07:40 PM | #6 |
Not Yet Wild
Join Date: Apr 2010
Location: Auburn,AL
Posts: 55
|
Re: cc slow to rev since upgrade
I cleaned the carb good today and still not any better. My buddy has a stock g9 and he blew right by me today. The motor is running good, the cart just doesnt want to get up and go. Any other suggestions?
|
01-01-2011, 08:29 PM | #7 |
Bad *** Speller!
Join Date: Oct 2009
Location: Columbus, Ohio
Posts: 1,338
|
Re: cc slow to rev since upgrade
jones lets look again and make sure the filter is good, your fuel is good, and the pump is clean, not full of some of that alabama crap that may be sitting in the diaghram. if the pump is gok and the supply is good, it still sounds like a carb issue.
it might be the air box leaking. meaning its not installed correctly, and its not being fully sealed. it will give you some hell! i twill take a few minutes to pop the top and check your filter and reinstall it to make sure it is installed correctly. also at the same time you could check you air tube form the filter box to the carb, to make sure its ok, not kinked or ripped allowing air to by pass the air box. give your spark plug a check to. see what the color of the tip looks like. is it the coorrect plug? gap ok? i know they sound stupid to check, but its usaully the simple thing that get you! |
01-01-2011, 11:19 PM | #8 |
Gone Wild
Join Date: Jan 2007
Location: La Porte Indiana
Posts: 1,392
|
Re: cc slow to rev since upgrade
well i will throw one out. is it possible the timing key was put in backward? i know silly but just a thought.
About how much louder do you think that exhaust is over stock? I have been wanting to do that swap to my campground cruiser when i swap in the 350. |
01-02-2011, 08:58 AM | #9 | |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,926
|
Re: cc slow to rev since upgrade
Quote:
In Maintenance mode with a timing key, my cart jumps to full RPM's VERY fast! When driving (under load), it's not as quick, but it's still a big difference from stock! As for the CCP exhaust, I did a thread on it a few years back, and I don't know if Tom changed anything since then, but, here it is: http://www.buggiesgonewild.com/video...e-exhaust.html |
|
01-02-2011, 11:47 AM | #10 |
Not Yet Wild
Join Date: Apr 2010
Location: Auburn,AL
Posts: 55
|
Re: cc slow to rev since upgrade
Guys, thanks for yhe help! I havent messed with the timing key. I am goiing to run through everything good this afternoon and hopefully figure it out. Vert, the exhuast is louder than I expected but once I got used to it I love it. Also let me know if you dont get your package in the next few days? If you want, Ill give you the tracking number.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
G1 Will Only Run Slow | Gas Yamaha | |||
91 ez-go slow after upgrade | Electric EZGO | |||
Slow! How do I make my club car Gasser go really slow. | Gas Club Car | |||
slow take off | Electric EZGO | |||
Slow Down | Electric EZGO |