|
08-07-2010, 08:11 PM
|
#1 |
|
Gone Wild
Join Date: May 2010
Location: OHIO
Posts: 1,517
|
annoying noice
hi guys i have a 87 clubcar and i bought it used and it makes a annoying noise i cant stand....
the noise comes near the 2 clutches, and its like eerrrrrrrrrrr and once it starts going it fine and does it on EVERY take off would it be a loose belt ?? a golf cart dealer recommended motor mounts ?? and also said the clutches are good OIL/rear end oil >????? to much or to little just thoughts please any  or suggestions tips trick I dont care as long as i get this fixed |
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
08-07-2010, 08:28 PM
|
#2 |
|
Gone Wild
Join Date: May 2010
Location: NW Indiana
Posts: 283
|
Re: annoying noice
does it resemble a bell ringing along with it....kinda muffled though? Mine was a worn front clutch ( drive ) and had it rebuilt and machined at CPP - Awesome results!
|
|
|
|
|
08-07-2010, 08:48 PM
|
#3 |
|
Gone Wild
Join Date: May 2010
Location: OHIO
Posts: 1,517
|
Re: annoying noice
the noise is more like high pitch eeerrrrrrpppp LOL and once it gets moving its fine and smooth
|
|
|
|
|
08-07-2010, 09:26 PM
|
#4 |
|
Gone Wild
Join Date: May 2010
Location: NW Indiana
Posts: 283
|
Re: annoying noice
Starter/generator belt loose? Hear it more when it is just starting the engine? Measure the drive belt too.....is it close to an inch?
|
|
|
|
|
08-07-2010, 09:29 PM
|
#5 |
|
Gone Wild
Join Date: May 2010
Location: OHIO
Posts: 1,517
|
Re: annoying noice
the starter/generator belt is tight as it can be and for the drive belt its an inch its a brand new belt as well
|
|
|
|
|
08-08-2010, 12:07 AM
|
#6 |
|
Gone Wild
Join Date: Jun 2010
Location: Snowy NW PA
Posts: 275
|
Re: annoying noice
Put it in service mode and see if you still get the noise.
If you do, to eliminate belt noise as a possibility, try a little water to spray down the belt/pulleys when running in service mode, see if the noise changes or goes away momentarily. If it does, take some fine sand paper (maybe 220) and take the shine off the pulleys. If it is the rubber belt squealing on the smooth polished surface, this trick may make it quit. |
|
|
|
|
08-08-2010, 07:48 AM
|
#7 |
|
Gone Wild
Join Date: May 2010
Location: OHIO
Posts: 1,517
|
Re: annoying noice
when its in service mode (neutral) and the clutches are moving it does not make the noise but out of service mode and the cart actually moves that when it make that noise that i cant stand
|
|
|
|
|
08-08-2010, 05:37 PM
|
#8 |
|
Gone Wild
Join Date: May 2010
Location: NW Indiana
Posts: 283
|
Re: annoying noice
Sounds like you have it narrowed down to the transmission or rear end.......maybe rear brakes dragging?
|
|
|
|
|
08-08-2010, 07:03 PM
|
#9 |
|
Gone Wild
Join Date: May 2010
Location: OHIO
Posts: 1,517
|
Re: annoying noice
i never did check the rear breaks, it rolls pretty good though
|
|
|
|
|
08-08-2010, 09:16 PM
|
#10 |
|
Gone Wild
Join Date: May 2010
Location: NW Indiana
Posts: 283
|
Re: annoying noice
Jack the rear end up and put it in neutral ( chocking the front wheels of course! ) and see if you can duplicate the noise by spinning the rear tires. Could just be a rust build up on the edge of the drums or something easy......
|
|
|
|
 |
|
||||||
| Thread Tools | |
| Display Modes | |
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| annoying reverse buzzer | Electric EZGO | |||
| annoying squeaky steering | Gas Yamaha | |||
| Faint beeping gets annoying! | Electric Yamaha | |||
Linear Mode
