lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car
Gas Club Car Gas DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 11-16-2010, 05:43 PM   #1
Not Yet Wild
 
Join Date: Nov 2010
Posts: 7
Default 2007 club car precedent gas carb problem I believe

Bought cart stock and ran for 10 hours or so and all was well.. Now its lifted with jakes 6" spindle and 23" tires. Has a problem staying runnung.. Will run for a mile or less and shut down, the generator will still be turning but no start of motor.. then after 5-7 seconds of it trying to start it will start and run maybe 50 - 70 feet or so and die again.. it will do this maybe every 3-4 rides, sometimes it will not do it at all and run fine.. the problem is getting worse and I need help.. The battery tested at 12.7 volts but when it tries to start dies down to 10.7 volts.. Any suggestions.
Limerock trucker is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 11-16-2010, 07:42 PM   #2
Not Yet Wild
Club Car
 
Join Date: Dec 2006
Location: Sebring, Florida
Posts: 54
Default Re: 2007 club car precedent gas carb problem I believe

Not sure it is same problem, but I had a 07 built that was sitting on a CC lot for a few months. Guy picked it up for me and drove it before doing lift etc. He delivered it and was perfect for a few days then it just quit running. Turned out fuel sitting in it had destroyed fuel lines and inside of fuel pump.
kipg is offline   Reply With Quote
Unread 11-17-2010, 07:38 AM   #3
Gone Wild
 
rose88's Avatar
Club Car
 
Join Date: Apr 2010
Location: West Tennessee
Posts: 1,054
Default Re: 2007 club car precedent gas carb problem I believe

Sounds like you are running the bowl dry on carb, and when it sit's it will slowly fill back up and run til dry again. I would clean carb and retry.

Or try this: When it stops again shut off the fuel valve at tank, and then put either on jack stands or jack up rear and try to crank. Pull hose off of end of carb that goes to air box, gently spray just a little carb cleaner in carb and try again if it hits you probably have a jet clogged or some trash in carb.

I have cleaned over 60 carbs this year alone (new record) 10% Ethanol????

Everything has been GREEN inside.

Let us know what you find out.
rose88 is offline   Reply With Quote
Unread 11-18-2010, 07:21 PM   #4
Not Yet Wild
 
Join Date: Nov 2010
Posts: 7
Talking Re: 2007 club car precedent gas carb problem I believe

Well I took the battery out and had it load tested, it was shot.. Installed new battery and cart is screaming around the neighbor hood, maybe 3-4 hours today with not one sputter. Haven't touched the carb at all. My luck is not this good so I am waiting on something to happen..Thanks for the help, Where are the stickies on this website..
Limerock trucker is offline   Reply With Quote
Unread 11-18-2010, 09:28 PM   #5
Gone Wild
 
rose88's Avatar
Club Car
 
Join Date: Apr 2010
Location: West Tennessee
Posts: 1,054
Default Re: 2007 club car precedent gas carb problem I believe

Quote:
Originally Posted by Limerock trucker View Post
Well I took the battery out and had it load tested, it was shot.. Installed new battery and cart is screaming around the neighbor hood, maybe 3-4 hours today with not one sputter. Haven't touched the carb at all. My luck is not this good so I am waiting on something to happen..Thanks for the help, Where are the stickies on this website..
When you go to the gas club car section look at the top they are in RED
rose88 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
2007 Club Car precedent Electric Club Car
Front End Wiring Diagram Club Car Precedent 2004 - 2007 Electric Club Car
2007 club car precedent wiring help Gas Club Car
2007 club car precedent in houston Golf Carts and Parts


All times are GMT -5. The time now is 10:21 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2019, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.