|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
12-20-2011, 02:16 PM | #1 |
Not Yet Wild
Join Date: Dec 2011
Location: Northwest Indiana
Posts: 23
|
1997 Club Car limo DS 11hp sputters on acceleration
Hello all..
I have a 97 DS Club Car with 11hp engine. The darned thing will run sometimes and other times just sputter upon throttle from a stop. If I play with the choke and get the RPMs up it will snap out of it for a little while. It's not the fuel pump or filter since the clown I purchased it from brought me a new pump and filter and even picked it up and put on another carb (supposedly..). I feel like a real idiot buying this thing, I only wanted to cruise the kids around Fort Wilderness in Disney (which is where I am now). To me it definitely feels like a lack of fuel issue, it even backfires at times out the exhaust. The guy I bought it from repairs golf carts, just not real well I guess. He has a business out of Florida and swears this cart ran great however I'm not having a lot of luck. Is there a rev-limiter on this? I've seen schematics of the limit switches and even saw that there is a service mode on the shifter. Which I checked and it already was in service mode. Any help on this would be greatly appreciated. I'm an auto mechanic so I can handle the tools very well. Sorry to make my first post a needy one.... |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
12-20-2011, 03:11 PM | #2 |
Gone Wild
Join Date: Dec 2007
Location: SE Indiana
Posts: 392
|
Re: 1997 Club Car limo DS 11hp sputters on acceleration
Sounds like a lean condition. Check to verify you are getting plenty gas to the carb. I had a similar situation and mine was a piece of dirt in the high speed jet in the carb, Cleaned it out and it ran perfectly. Make sure there isn't too much play in the throttle shaft on the carb. This can give a lean condition. Lastly I would unbolt the muffler and see if condition goes away- possible clogging.
|
12-20-2011, 03:26 PM | #3 |
Not Yet Wild
Join Date: Dec 2011
Location: Northwest Indiana
Posts: 23
|
Re: 1997 Club Car limo DS 11hp sputters on acceleration
Sounds feasible but it doesn't do it all the time.
A new development If it is sputtering if you ease out of the throttle it will clear and then start to rev and accelerate. You mentioned the throttle shaft and I've read that also somewhere. The seller insists that you can't throttle too fast because the rev limiter kicks in. I know how a rev limiter works and this is just a load of bs from him. I'll check on the shaft when I get it home. Can weak compression cause an erratic symptom like this? I know the pump is impulse style and relies on compression to work. |
12-20-2011, 04:08 PM | #4 |
Getting Wild
Join Date: Dec 2011
Location: Indiana
Posts: 124
|
Re: 1997 Club Car limo DS 11hp sputters on acceleration
rev limiter has nothing to do with this. i've seen plugged mufflers and air leaking around the intake do this. club car issued a bulletin to cover this problem.
|
12-20-2011, 04:10 PM | #5 |
Getting Wild
Join Date: Dec 2011
Location: Indiana
Posts: 124
|
Re: 1997 Club Car limo DS 11hp sputters on acceleration
example:
|
12-20-2011, 05:10 PM | #6 | |
Not Yet Wild
Join Date: Dec 2011
Location: Northwest Indiana
Posts: 23
|
Re: 1997 Club Car limo DS 11hp sputters on acceleration
Quote:
Anyway, a clogged muffler will intermittantly cause a hard accel and sputter? Or would it be more consistent? Can choking the motor cause the thing to snap out of it? Based on the autos I fix, clogged exhaust is consistent. It may run slightly better at startup but once warm it's bad all the time. I see you're from Valpo, I live in Crown Point. |
|
12-20-2011, 05:35 PM | #7 |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,933
|
Re: 1997 Club Car limo DS 11hp sputters on acceleration
If the air filter was replaced, and it runs better with the choke...
Double check the air box cover to make sure that it's been reinstalled correctly! (unsnap it, make sure the rear hooks are hooked properly, and resnap it!) It's crucial that the air box is sealed tightly! my .02 |
12-20-2011, 07:42 PM | #8 | |
Not Yet Wild
Join Date: Dec 2011
Location: Northwest Indiana
Posts: 23
|
Re: 1997 Club Car limo DS 11hp sputters on acceleration
Quote:
When it does bog down you can hear it through the intake/choke assembly under your legs. It definitely is lacking fuel from the way it sounds. |
|
12-20-2011, 10:03 PM | #9 |
Gone Wild
Join Date: Aug 2010
Location: Central Florida
Posts: 1,506
|
Re: 1997 Club Car limo DS 11hp sputters on acceleration
mine was doing this same thing only way it would run was by feathering the choke. took the bowl off the carb and there was some water in it. buddy emptied it out took the main jet out blew threw it put it back together it runs fine now. pop the bowl off to see what you get.
|
12-21-2011, 08:48 AM | #10 |
Not Yet Wild
Join Date: Dec 2011
Location: Northwest Indiana
Posts: 23
|
Re: 1997 Club Car limo DS 11hp sputters on acceleration
QUOTE=KRAZYMATT;663638]mine was doing this same thing only way it would run was by feathering the choke. took the bowl off the carb and there was some water in it. buddy emptied it out took the main jet out blew threw it put it back together it runs fine now. pop the bowl off to see what you get.[/QUOTE]
Popped the bowl off and found some seditment. Cleaned it out and still the same. Checked the jet and cleaned that out too even though it looked clear to begin with. RESULT? Same problem. [ |
Tags |
club car bogs sputters |
|
|
Similar Threads | ||||
Thread | Forum | |||
'83 club car acceleration problem | Electric Club Car | |||
1997 Club Car limo won't go forward on first two tries | Electric Club Car | |||
sputters w/acceleration | Gas Club Car | |||
sputters on acceleration | Gas EZGO | |||
96 Club car sputters and will not accelerate | Electric Club Car |