|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
06-14-2012, 08:03 AM | #1 |
Not Yet Wild
Join Date: May 2011
Location: OKLAHOMA
Posts: 12
|
Engine wont crank unless i jump across the solonoid
JUST AQUIRED ME A '87 GAS CLUB CAR , HOPEING SOMEONE CAN GIVE ME A LITTLE GUIDANCE FIGURING OUT WHY IT WONT START,
ill give you all i know about the cart, it did run, the prev. owner actually jump started it with a 24v system and burnt the starter up, after replaceing starter i was successful to get it to start 1 time jumping acrossthe solonoid but died and now has no spark, plus dont know why i have to jump across solonoid HOW DO I TEST THE SOLONOID AND MICRO SWITCHES ? THANKS FOR ANY HELP |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-16-2012, 11:22 AM | #2 |
Not Yet Wild
Join Date: May 2012
Location: Whitmore Lake, MI
Posts: 34
|
Re: Engine wont crank unless i jump across the solonoid
Testing the solenoid is simple. When your key is on and your direction selector is on forward, press the gas pedal. You should hear a decent click. No click means a bad limit switch, solenoid, fuse, or wire. The fuse and the wiring are both quick checks. To check your switches, put a continuity tester on each terminal and test when the switch is off and when it is pressed. An ohmmeter will suffice if you do not have a continuity tester. Set it on 200 ohms and test. Anything below 1 ohm means continuity. Most of the time those don't go bad though. I have almost 80 carts over 10 years old and have seen one replaced. Most likely it is your solenoid.
|
06-18-2012, 12:02 PM | #3 |
Not Yet Wild
Join Date: May 2011
Location: OKLAHOMA
Posts: 12
|
Re: Engine wont crank unless i jump across the solonoid
thank you i will move forward with you suggestions, you are big help !!!!
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Help installing crank on 88 EZGO engine rebuild | Gas EZGO | |||
Robin engine crank play.Rebuild or trash? | Gas EZGO | |||
Ezgo gas wont crank | Gas EZGO | |||
95 club car 48v wont run without bypassing solonoid | Electric Club Car | |||
Slow to crank engine over | Gas Yamaha |