|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
10-22-2012, 08:37 PM | #1 |
Not Yet Wild
Join Date: Oct 2012
Posts: 4
|
Gas filling motor locking it up.
Just bought it and guy said it was good for kids. 2 problems with it. Problem 1 the car runs good once it gets going then while parked it fills the motor with gas and will not turn over. I take plug out turn it over to pump gas out and it will run. Problem 2 it appears the choke is not working because it is extremely hard to get started. It just spins over and over. Any help would be greatly appreciated. Thanks.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-22-2012, 08:41 PM | #2 |
I Refuse To Get Stuck!!!
Join Date: Jun 2010
Location: Hilton,NY
Posts: 5,427
|
Re: Gas filling motor locking it up.
It sounds like your float is sticking,or the needle/seat is sticking.Either one will flood it out.If it floods,remove the spark-plug and turn it over by hand to clear the fuel from the cylinder.Too many people pull the plug and spin it with the starter,then the spark-plug ignites the fuel and you have a fire!Trying to turn it over,full of fuel is a good way to bend the rod as well.When it floods,clean the plug while its' out,the fuel is soaking it,causing hard-starting.Hope this helps.
|
10-22-2012, 08:45 PM | #3 |
Not Yet Wild
Join Date: Oct 2012
Posts: 4
|
Re: Gas filling motor locking it up.
Thanks for the quick reply. I will turn it over by hand this time. I will take the carb off and have someone look at it. I took the bowl off and cleaned it out. I don't trust myself more than that. Thanks again.
|
10-23-2012, 05:34 PM | #4 | |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: Gas filling motor locking it up.
Quote:
|
|
10-23-2012, 06:41 PM | #5 |
Gone Wild
Join Date: Sep 2012
Location: Michigan
Posts: 351
|
Re: Gas filling motor locking it up.
Probably have gas in your engine oil now also, better check it. I agree you need carb work
|
10-23-2012, 07:50 PM | #6 |
Not Yet Wild
Join Date: Oct 2012
Posts: 4
|
Re: Gas filling motor locking it up.
Thanks guys. I will have someone look at it or rebuild it. I will also change the oil and filter in case gas got it there. Really nice to have people help.
|
11-30-2012, 05:39 PM | #7 |
Gone Wild
Join Date: Nov 2009
Posts: 250
|
Re: Gas filling motor locking it up.
I have had the same exact problem....pulled the plug and hit the pedal......FIRE!!!!!!!!!!!!!!!!!!!!!!!!!!!
What happened was just what was said...float stuck open...draining gas into motor. I drained the oil...had 1 gal of gas in it!!! Take carb off and give it a good cleaning...should be fine! S |
|
|
Similar Threads | ||||
Thread | Forum | |||
filling holes | Body and Paint | |||
Filling holes | Body and Paint | |||
Muffler filling up with gas | Gas EZGO | |||
Cylinder & crankcase filling with gas | Gas Club Car | |||
Battery Filling System | Electric EZGO |