01-11-2014, 10:54 PM | #1 |
Gone Wild
Join Date: Sep 2010
Location: Angleton,TX.
Posts: 177
|
My 2000 CC DS lost spark
My 2000 club car ds lost spark today. It was running fine this morning with no problems. It turns over fine... I thought it was the carb so I cleaned it but, it wasn't take. I replaced the spark plug and snap it into the spark plug wire and grounded it out on the motor and no spark. I checked also all the grounds on the cart and all of them are good. What could it be???
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
01-12-2014, 08:12 AM | #2 |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,900
|
Re: My 2000 CC DS lost spark
The 2 most common problems with loosing spark on a Kawi FE engine are either the Rev limiter, or the Coil is bad.
First check the Rev limiter, (lower front of the engine #22) Remove (do not cut) the ground wire that attaches to the left hand mounting bolt, reinstall the mounting bolt, (without the wire) tape up the eyelet, and see if it starts and runs, If so... you have a bad Rev limiter, and they're not cheap! so if you don't have the $ to replace it, and IF... the governor is set at the factory settings, you can leave the ground disconnected. I, personally would suggest replacing the limiter though! If it still won't start, then in most cases it'll be the coil, (#20) and it's not fun replacing it! Limiter ground wire and bolt is at #13 hope this helps! |
01-12-2014, 12:57 PM | #3 |
Gone Wild
Join Date: Sep 2010
Location: Angleton,TX.
Posts: 177
|
Re: My 2000 CC DS lost spark
Thanks for the quick response and great info... I'll try it.
|
01-13-2014, 10:09 PM | #4 |
Gone Wild
Join Date: Sep 2010
Location: Angleton,TX.
Posts: 177
|
Re: My 2000 CC DS lost spark
It was the rev limiter.
|
01-13-2014, 10:44 PM | #5 |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,900
|
Re: My 2000 CC DS lost spark
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
2000 CC lost power question | Electric Club Car | |||
87 ezgo lost spark | Gas EZGO | |||
2000 TXT Has No Spark | Gas EZGO | |||
Lost spark ? | Big Block Talk! | |||
lost spark again | Gas Club Car |