lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car
Gas Club Car Gas DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 04-24-2014, 09:05 PM   #1
Not Yet Wild
 
Join Date: Apr 2014
Posts: 3
Default How do I wire start and run with a key instead of pedal start/stop

Greetings,
I just purchased a 2009 Gas Club Car Precedent and would like to wire it to start and run with a key switch instead of using the gas pedal switch. Any assistance on this modification would be appreciated.
Thanks!
Trent
Trentrent is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 04-24-2014, 11:09 PM   #2
Not Yet Wild
 
hamy's Avatar
Club Car
 
Join Date: Mar 2012
Location: oregon
Posts: 68
Default Re: How do I wire start and run with a key instead of pedal start/stop

There is a thread in clone engine swap called "wiring ignition to turn off engine". It worked for me very well. Not sure if the precedent is the same though.
hamy is offline   Reply With Quote
Unread 04-25-2014, 10:32 AM   #3
.......BGW........
 
Join Date: Apr 2009
Location: FT Lauderdale FL.
Posts: 15,286
Default Re: How do I wire start and run with a key instead of pedal start/stop

Welcome to BGW

read this thread

http://www.buggiesgonewild.com/gas-c...dle-setup.html
rib33024 is offline   Reply With Quote
Unread 05-01-2014, 08:30 PM   #4
Not Yet Wild
 
Join Date: Apr 2014
Posts: 3
Default Re: How do I wire start and run with a key instead of pedal start/stop

Lift up the rubber floor mat. Lift up the plate that covers the wiring in front of the gas pedal. There are 5 wires running from the 2 microswitches inside the pedal assy. Clip the black/white wire. Tape off the ends. Turn up the idle screw on the carb a touch. Everything works flawless. Turn on key and step on gas to move. Turn off key to shut off.
Trentrent is offline   Reply With Quote
Unread 05-01-2014, 09:39 PM   #5
.......BGW........
 
Join Date: Apr 2009
Location: FT Lauderdale FL.
Posts: 15,286
Default Re: How do I wire start and run with a key instead of pedal start/stop




Quote:
Originally Posted by lockman1 View Post
It's really simple! and It's not my idea... Tom @ CPP told me about it!

(Note: I don't know if this works for PRE-1992 DS Club Cars!)

Put your cart in maintenance mode, chock the wheels... and the key off!

In the engine compartment, There is a black plastic box, just below the drivers seat!

Remove the one hex screw, and then the cover for the box,
You'll see the voltage regulator, two micro switches, a single 10 amp fuse, and a bunch of wires!

Go to the micro switches... wipe the dirt off of the micro switch wires (without disconnecting them)

There should be only one solid black wire...
(I think it's on the bottom micro switch)

Disconnect the solid black wire ONLY! (pedal kill circuit)
and set the wire off to the side, (inside the box) and reinstall the cover!

You are now ready to adjust your idle!

Again... with the cart in maintenance mode, and the wheels chocked,
Turn the key on, push the "GO" pedal to start it...
and adjust your idle up just high enough so the drive belt is just about ready to turn
(if the drive belt turns too much, the cart will "creep" while idling!)

Turn the key off to shut it down, set the brake,
take the cart out of maintenance mode, and remove the wheel chocks.

Test drive (start and stop) to make sure it won't stall or creep... and adjust if needed!

Your cart will now start with the pedal... idle... and shut off with the key!

rib33024 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
anyway to get rid of stop/start? Gas Yamaha
Start and stop Gas Yamaha
whats the difference between a key start and pedal start fe350ccw? Gas Club Car
Can I start and stop my vanguard with the pedal? Big Block Talk!
Start and stop Electric EZGO


All times are GMT -5. The time now is 03:10 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2019, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.