lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas golf carts > Gas Columbia ParCar


Post New Thread  Reply
 
Thread Tools Display Modes
Old 05-31-2011, 08:15 PM   #1
Not Yet Wild
 
Join Date: Apr 2009
Posts: 15
Default ParCar not charging, but Generator works????

Again not sure on the year of my ParCar Gas 2 stroke cart.

But I just bought a new battery and jacked it up and drove it in the air to get a voltage reading on the generator.
It was NOT charging the battery.
I started searching the forums, and found a PDF that said to disconnect the green wire/ DF wire and ground the terminal while checking the voltage.
Upon doing so I saw that the generator DOES work, as it put out 16V before I stopped revving it up.
Unfortunately the PDF does not say what to do after that, it goes on to assume that it doesnt work and that you need to put new brushes into the generator.

So my generator DOES work, but something is NOT charging the battery.
I tested conductivity of the green wire and it is going to the positve side of the circuit. (not sure if its supposed to)
But how do I get this to charge while its driving?
What are my next troubleshooting steps?
Thanks!!!!!!
rob4448585 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 05-31-2011, 08:23 PM   #2
Not Yet Wild
 
Join Date: Apr 2009
Posts: 15
Default Re: ParCar not charging, but Generator works????

I think it points to the voltage regulator as being the culprit.
Where is that located,
What does it look like?
rob4448585 is offline   Reply With Quote
Old 05-31-2011, 08:29 PM   #3
Not Yet Wild
 
Join Date: Apr 2009
Posts: 15
Default Re: ParCar not charging, but Generator works????

is this it?

http://www.buggiesunlimited.com/golf...G%20UNV%202633

what abouts is this thing located?
I want to make sure the wires are plugged in on this still
rob4448585 is offline   Reply With Quote
Old 06-06-2011, 11:23 PM   #4
Getting Wild
 
mvparcar's Avatar
Columbia
 
Join Date: Aug 2009
Location: pgh,pa
Posts: 126
Default Re: ParCar not charging, but Generator works????

either the voltage regulator(most likely)or the electric ignition was my problem
mvparcar is offline   Reply With Quote
Old 06-07-2011, 12:46 AM   #5
Not Yet Wild
 
Join Date: Apr 2009
Posts: 15
Default Re: ParCar not charging, but Generator works????

I think it is the voltage regulator but how do I test it?

Also how do I find out what year my cart is?

It uses a square regulator with a hole in it, all the info I found online says thats a 4 stroke regulator, where mine is a 2 stroke.
rob4448585 is offline   Reply With Quote
Old 06-14-2011, 03:23 PM   #6
Getting Wild
 
mvparcar's Avatar
Columbia
 
Join Date: Aug 2009
Location: pgh,pa
Posts: 126
Default Re: ParCar not charging, but Generator works????

use a voltmeter and check the wires leaving the regulator, i did this like a year ago with a neighbor helping me whos a pro mechanic that worked on everything. jack it up start it and see if you volts rise at battery then regulator. i gave up and took mine to a shop.
mvparcar is offline   Reply With Quote
Old 06-14-2011, 03:29 PM   #7
Not Yet Wild
 
Join Date: Apr 2009
Posts: 15
Default Re: ParCar not charging, but Generator works????

ill update the thread.......


So before I bought a new regulator, I probed the wires for continuity and also to make sure they were getting the power/ground and green wire signal they were supposed to.
All were fine, so only thing left would be the regualtor is bad.
I don't know what year my golf cart is, my research said that I should have an older 2 stroke regulator on my cart, but I had a newer 4 stroke regulator on it (hole in the middle to mount it)
I purchased a new regulator, installed it, fired it up and tested the voltage, and it has the correct 14+ volts while it runs.
rob4448585 is offline   Reply With Quote
Old 05-07-2013, 04:45 PM   #8
Not Yet Wild
 
Join Date: Nov 2012
Posts: 8
Default Re: ParCar not charging, but Generator works????

Which one did you use the older 2 stroke one or the newer 4 stroke one?

Thanks
paulvchip is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas golf carts > Gas Columbia ParCar


Thread Tools
Display Modes


Similar Threads
Thread Forum
generator not charging! Gas Club Car
charging with a generator Electric EZGO
generator not charging Gas Club Car
Charging your cart using a generator Electric EZGO
Starter/Generator not charging. Gas EZGO


All times are GMT -5. The time now is 11:00 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2014, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.