lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas EZGO
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV.



Post New Thread  Reply
 
Thread Tools Display Modes
Old 03-31-2015, 07:26 AM   #1
bigonpig
Not Yet Wild
 
Join Date: Jul 2014
Posts: 22
Default Micro (limit?) switch testing

I just picked up a 1993 4 cycle EZGo with the 295 Pre-MCI Robin engine. I replaced the starter/generator, solenoid, and battery, and I re-did some of the old (corroded) wiring. I think the micro switch is either wired incorrectly or is bad because when I turn the key to on, the starter/generator runs without depressing the gas pedal. Is there a way to test this switch with a voltmeter or should I just replace that too?
bigonpig is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 03-31-2015, 07:52 AM   #2
cart around
Test before replacing
 
cart around's Avatar
E-Z-GO
 
Join Date: Aug 2013
Location: Ohio side of the Pennsylvania border.
Posts: 3,491
Default Re: Micro (limit?) switch testing

Disconnect the wires, and set your meter on ohms. It should read open, and closed circuit depending on the position. You should also hear it clicking while operating the switch.

It's nothing more than a spring loaded lever with a set of contacts.
cart around is offline   Reply With Quote
Old 03-31-2015, 12:06 PM   #3
bigonpig
Not Yet Wild
 
Join Date: Jul 2014
Posts: 22
Default Re: Micro (limit?) switch testing

Ok, I'll try that out tonight. Thanks for your help!
bigonpig is offline   Reply With Quote
Old 05-22-2015, 11:07 AM   #4
bigonpig
Not Yet Wild
 
Join Date: Jul 2014
Posts: 22
Default Re: Micro (limit?) switch testing

Long delayed reply. The microswitch was bad so I replaced it. Thanks for the help!
bigonpig is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas EZGO


Thread Tools
Display Modes


Similar Threads
Thread Forum
98 Club Car 36v resistor no micro(limit) switch! Electric Club Car
speed limit switch Electric Club Car
What is G14E Limit switch? Electric Yamaha
Forward Reverse switch limit switch Electric Club Car


All times are GMT -5. The time now is 02:29 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.