|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
03-04-2016, 09:26 PM | #1 |
Not Yet Wild
Join Date: Feb 2016
Posts: 10
|
03 EZGO Bogs down after 5 minutes
Hey guys,
Im having the same issue like everyone else but I cant seem to find the right thread on here to solve my issue. I purchased an 03 ezgo txt 295cc, and since i purchased it i managed to do the following. 1.) change spark plugs/ filter/ oil 2.) clean out carb 3.) check fuel pump....works 4.) valves are set to .004 The issue.....after 5 to 10 minute runs my golf cart starts to bog down. When i pull the choke a little bit it begins to work again.....im afraid to keep running it with the choke on. Questions 1.) is this normal to pull the choke when this issue happens? 2.) could it be a coil issue? History facts: 1.) i checked fuel flow and it works great 2.) gas cap is removed when bogs down and the cart still has an issue. I see so many threads on here where the issue is so minor, so your input would be great in solving this one before my wallet ends up screaming at me |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-04-2016, 09:52 PM | #2 |
Not your usual outlaw
Join Date: Oct 2008
Location: Near Lake Geneva, WI
Posts: 20,054
|
Re: 03 EZGO Bogs down after 5 minutes
I'm gonna say if it's not a fuel filter, pull the carb and completely clean it. if that doesn't work than it may be rings? Check compression??
|
03-04-2016, 10:31 PM | #3 |
Not Yet Wild
Join Date: Mar 2016
Posts: 8
|
Re: 03 EZGO Bogs down after 5 minutes
Although I am not an expert in golf carts, i am pretty good with engines. When you say you cleaned the carb did you pull both jets and run a piece of wire thru them? Cleaning the gunk out of the bowl doesnt clean the jets. Also when you set the valves was it at the cam or the valve? I adjusted mine wrong the other day and they were too tight at the cam. They are supposed to be adjusted so the arm to cam clearance is .004.
Since it bogs after it is warm I wouldnt suspect compression. You would have more issues when cold if it were compression. the piston grows with heat and makes the compression higher. I would bet it is a clogged jet or tweaking the air fuel knob. I know it doesnt change much but it could be a combination of the two. Bog usually means lean. |
03-04-2016, 11:07 PM | #4 |
Not Yet Wild
Join Date: Feb 2016
Posts: 10
|
Re: 03 EZGO Bogs down after 5 minutes
I agree on the compression comment.....what about the coils? I am waiting for an argument to rule this out.
As for the carb cleaning , i just managed to remove the bowl and spray carb cleaner in every hole. |
03-05-2016, 09:29 AM | #5 |
Doin' the Wild Thang
Join Date: Mar 2010
Location: Greenville, AL
Posts: 1,063
|
Re: 03 EZGO Bogs down after 5 minutes
There is definitely two good points here that need to be covered... A thorough carb cleaning will have to be a removal of the carb and pull the jets and cleaned to ensure that all visible passages are clear... Blow it out good and clean and install... The other point of compression, seeing as it quits after getting hot is also legit... The Fuji 295 and 350 are notorious for mushrooming the intake valve and you constantly have to adjust valve lash... Also, electrical components tend to find weak spots and fail when heat builds up.. I would start with the carb and valves and see what you come up with... Compression values are critical...
|
03-05-2016, 09:44 AM | #6 |
Not Yet Wild
Join Date: Feb 2016
Posts: 10
|
Re: 03 EZGO Bogs down after 5 minutes
Okay so i woke up early this morning, and said "nothing is better than cleaning out a carb on a Saturday morning"!
After opening the carb i noticed once again sediment was residing in the bowl. It wasnt as bad as the first time cleaning it..... but it was noticible. After cleaning out All parts of the carb and putting it back on , i managed to have a good 20 minute run with no issues.......fingers crossed i hope this solved the problem. Anyway this leaves me with following questions. 1.) was the little bit of sediment that was left in the carb bowl and needle be enough to make my golf cart bog down? I can only drive this around the block so many times, since im afraid to go far and get stuck. |
03-05-2016, 09:48 AM | #7 |
Not Yet Wild
Join Date: Feb 2016
Posts: 10
|
Re: 03 EZGO Bogs down after 5 minutes
|
03-05-2016, 09:59 AM | #8 |
Gone Wild
Join Date: Dec 2013
Location: SE Louisiana
Posts: 257
|
Anything hanging out in the bowl can get sucked up and partially impede an air passage....and it won't run right. Since you didn't do a thorough cleaning the first time, the sediment you found was probably hiding after the first cleaning. You loosened it up, but it didn't break loose until the gas started sloshing around.
You should probably clean it a couple more times after running it a while each time just to make sure you have it all. Sent from my SAMSUNG-SM-N910A using Tapatalk |
03-05-2016, 10:06 AM | #9 |
Not Yet Wild
Join Date: Feb 2016
Posts: 10
|
Re: 03 EZGO Bogs down after 5 minutes
So to confirm this sediment could of been the probable cause?
also there should be no sediment whats so ever?? |
03-05-2016, 10:14 AM | #10 |
Not your usual outlaw
Join Date: Oct 2008
Location: Near Lake Geneva, WI
Posts: 20,054
|
Re: 03 EZGO Bogs down after 5 minutes
Both very accurate statements! If you do not have a fuel filter on this cart, get one. You probably have a significant amount of sentiment in the old gas tank and you need to keep that out of the carb. Also, make sure you have a clean and appropriate air filter, same reason.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2002 EZGO TXT dies after 20 minutes. | Gas EZGO | |||
EZGO TXT 2001 Will Run for Ten Minutes and then Only Idle | Gas EZGO | |||
pds drive ezgo shuts off after 15-20 minutes of continual use | Electric EZGO | |||
2008 EZGO RXV Died in Minutes of Driving. Very frustrated. | Electric EZGO | |||
g-16 bogs down at 10 mph and up? | Gas Yamaha |