ezgo gas engine volt drop and dynastarter getting hot

eracer82

ezgo gas engine volt drop and dynastarter getting hot

when the engine is running and when i give gas power to the engine
the dynastarter gives 12.7 volts on the battery

but if i dont give anny gas the voltage is dropping slowly 12.5 12/3 and so on till the battery voltmeter gives 0 voltage

who can help me whit this problem

BGW

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum

eracer82

i am from the netherlands so pls dont look at my wrighting

cart around

What year is your cart?

Your voltages show that it is running on the battery.

Your generator should be putting out around 14 volts.

Battery voltage is 12.7v, and drops as it gets used.

I suspect the voltage regulator, but it needs to be tested first.


I only speak one language. I believe that you speak at least three. You have my respect for that.

eracer82

it is from year 2000
voltage regulator is not original any more

this 1 is on the cart now

if i give gas it gives 14v
if i dont it the engine is ideling then it shows only what is in the battery

some times it has a peek above 14v if i give power to the engine

cart around

It sounds like the generator is working. I still suspect the voltage regulator.

Here is a test. http://www.buggiesgonewild.com/gas-e...ng-system.html

Spicyunicorn

Nothing wrong with 14 volts when charging 15 or above is when you're getting a little to much

eracer82

ok next problen i replaced the volt regulator still the same

now i tought the solenoid and it is getting hot

dont tell me it is the solenoid haha

i started the engien again to feel the wires if somting els is getting hot the earth cable is getting hot 2

cart around

There is high resistance somewhere.

Disconnect each wire, and clean with sandpaper.

eracer82

i did that had the same problem all points are clean

now the engine wil not start any more solonoid is clicking but teh dynastarter wil not turn 12.5 v in the battery

cart around

Put your meter on the battery.

What is the voltage?

Then step on the gas pedal.

What does the battery voltage drop to?


That is a load test. If it drops down to 9.6 volts, the battery is bad.