|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
04-26-2017, 06:15 PM | #1 |
Not Yet Wild
Join Date: Apr 2017
Posts: 14
|
ezgo gas robins eh29c no power on hills
I have a ezgo gas golf cart with a robins ex29c I just installed a new engine it runs perfect on flat but know power on hill heres what I did so far I check valves there good I checked sparked it good I checked timing its good fuel filter good fuel pump good compression good I took carb apart it also new its clean looks good its when u go up a hill its like hardly a power I put a new belt the clutches are opening and closing I jack it up it runs smooth but not real snappy any thoughts thanks ahead of time
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-26-2017, 06:45 PM | #2 |
Gone Wild
Join Date: Aug 2009
Location: Santuck,Al
Posts: 1,747
|
Re: ezgo gas robins eh29c no power on hills
If the drive belt is not worn down (width) I would bet the problem lies within your driven clutch .
|
04-26-2017, 07:50 PM | #3 |
Not Yet Wild
Join Date: Apr 2017
Posts: 14
|
Re: ezgo gas robins eh29c no power on hills
the old belt was worn on the width so I put new one on but still lazy on hill which clutch u think it would be front or back thanks
|
04-26-2017, 08:20 PM | #4 |
Gone Wild
Join Date: Aug 2009
Location: Santuck,Al
Posts: 1,747
|
Re: ezgo gas robins eh29c no power on hills
I would check the rear (driven) clutch.
|
04-27-2017, 09:59 AM | #5 |
Getting Wild
Join Date: Sep 2008
Location: longview tx
Posts: 81
|
Re: ezgo gas robins eh29c no power on hills
are you fat "its just a thought:
|
04-27-2017, 04:12 PM | #6 |
Not Yet Wild
Join Date: Apr 2017
Posts: 14
|
Re: ezgo gas robins eh29c no power on hills
hey 410 man no I'm not fat its actually for our disabled son who has trouble walking trying to fiqure out whats wrong with golf cart so he can get out a little bit not getting in a pissin match with someone
|
04-27-2017, 04:15 PM | #7 |
Not Yet Wild
Join Date: Apr 2017
Posts: 14
|
Re: ezgo gas robins eh29c no power on hills
hey big mule I jack up cart ran both clutches open an close belt goes up an down how do u tell if they are bad thanks
|
04-27-2017, 05:26 PM | #8 |
Gone Wild
Join Date: Aug 2009
Location: Santuck,Al
Posts: 1,747
|
Re: ezgo gas robins eh29c no power on hills
With the drive belt removed grab both sheaths (each side of where the belt rides) of the rear clutch and try to "twist" them by holding the inside sheath while pulling the outer sheath towards the front of the cart,if you can twist it easily then your spring is either weak or broken.I'm not very good at explaining how to do stuff so hope you understand what I'm saying ,if not please don't hesitate to say so and I'll try again,also I'm sure some more members will be along shortly with tips to help you get it climbing hills again for your son .
|
04-27-2017, 07:25 PM | #9 |
Getting Wild
Join Date: May 2016
Posts: 122
|
Re: ezgo gas robins eh29c no power on hills
Are you fat.. jesus.. how is that even a question? These carts are designed to haul 800 pounds around a golf course, I highly doubt someone's weight is going to affect it.
I would try running a slightly smaller than factory belt. It helps change the gearing a little bit and makes it a bit torquier. It also lowers the top speed a little, but I am guessing that isn't a big deal for you. Good luck! |
04-27-2017, 07:37 PM | #10 |
Not Yet Wild
Join Date: Apr 2017
Posts: 14
|
Re: ezgo gas robins eh29c no power on hills
big mule ok I just went out took belt off held rear inner side pulley an yes I can turn outside part forward about half turn with lil pressure your thoughts thanks
|
|
|
Similar Threads | ||||
Thread | Forum | |||
1999 EZgo TXT no power on hills | Electric EZGO | |||
Compression for EH29C Robins engine | Gas EZGO | |||
1993 EZGo lacking power up hills with new batteries | Electric EZGO | |||
Power of a Robins 292 cm 9hp | Gas EZGO | |||
'96 EZGO - slight power loss up hills | Gas EZGO |