|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
06-04-2017, 09:29 PM | #1 |
Not Yet Wild
Join Date: Jul 2011
Location: DeKalb IL
Posts: 2
|
295cc Ezgo pouring gas out of breather tube, question about carb
295 Robbins cranks won't start. Has fuel, air, spark. Motor cranks, fills up, and spits fuel out of crank breather tube.
If I inject starting fluid directly into carb, the motor fires right up and runs........ (keep extinguisher close!) My main question is if the valves were out of sink, would it turn over with staring fluid? It's obviously getting fuel as the case is filling with it. Carb seemed fine when I inspected jets and passages. Any help greatly appreciated! |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-05-2017, 07:04 AM | #2 |
Gone Wild
Join Date: Aug 2012
Location: South central IL
Posts: 287
|
Re: 295cc Ezgo pouring gas out of breather tube, question about carb
If it runs good with starting fluid, then the valve timing should be OK. A stuck float in the carb or a dirty needle valve is likely the cause of the engine being flooded- or if you have a fuel pump that is operated by crancase pressure, then the fuel pump diaphragm may be ruptured and that may be the source of all the gas.
|
06-05-2017, 07:56 AM | #3 |
Gone Wild
Join Date: Feb 2008
Location: Brooklyn, Michigan "Home of M.I.S."
Posts: 3,666
|
Re: 295cc Ezgo pouring gas out of breather tube, question about carb
|
06-20-2017, 10:16 AM | #4 |
Not Yet Wild
Join Date: Jun 2017
Location: panama city beach florida
Posts: 54
|
Re: 295cc Ezgo pouring gas out of breather tube, question about carb
float needle has trash under it/float may have hole in it/or fuel pump are likely suspects I wouldn't run it with a crank case full of oil not for fear of fire but because its not lubricating the internals properly clean carb good change oil and you should be ok
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
oil in breather tube? | Gas EZGO | |||
Breather tube for workhorse | Gas EZGO | |||
Losing oil through breather tube | Gas Yamaha | |||
breather tube | Gas Columbia ParCar | |||
Gas pouring out of tube underneath cart | Gas Club Car |