lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas EZGO
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV.



Post New Thread  Reply
Thread Tools Display Modes
Unread 11-20-2017, 11:23 AM   #1
wmg
Not Yet Wild
 
Join Date: Aug 2014
Posts: 6
Default 2014 TXT stopped

Have a 2014 TXT gas. Was between holes 12 & 13 the cart sputtered and stopped. When I tried to start nothing happened. Lifted the seat and when pedal stepped on you could see the starter trying to turn. Left sit for an hour or so then tried. Started to turn engine but not fast enough to get engine running. Ok thought bad battery. Had battery tested but came up good. Have had the charger on battery on slow charge over night. Before I put in cart want to know what to check for seems like it is not charging. What is procedure to check charging? Have checked wires and all seem to be connected. Grounds appear ok. Ran like a charm until now.
wmg is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 11-20-2017, 01:00 PM   #2
Gone Wild
Yamaha
 
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,079
Default Re: 2014 TXT stopped

Put battery back in and put cart in nuetral and hook a meter to battery leads start cart and run it wide open the meter should read around 14-15ish volts if it's charging correctly
Spicyunicorn is online now   Reply With Quote
Unread 11-20-2017, 04:30 PM   #3
wmg
Not Yet Wild
 
Join Date: Aug 2014
Posts: 6
Default Re: 2014 TXT stopped

Charged the battery and it showed 13.6 volts. Put back into machine and set in neutral. Pressed the pedal and it spun for about 20 seconds but the engine did not really start. Now there is nothing at all. Checked the grounds and all are clean and tight. There is on the forward reverse switch only one wire attached. There is a second wire that seems to be dangling with a slip connector that joins two wires. There does not seem to be a location on the switch for this wire but makes no sense that there is only one wire on the switch. Any suggestions?
wmg is offline   Reply With Quote
Unread 11-22-2017, 02:56 PM   #4
wmg
Not Yet Wild
 
Join Date: Aug 2014
Posts: 6
Default Re: 2014 TXT stopped

Is there a wiring diagram available for this unit? want to check if there is a solenoid or something that might have failed and if so hao to check it for continuity
wmg is offline   Reply With Quote
Unread 11-22-2017, 04:39 PM   #5
wmg
Not Yet Wild
 
Join Date: Aug 2014
Posts: 6
Default Re: 2014 TXT stopped

Got it! Had a loose wire under the cover where the solenoid is and the switch on the Fwd/Rev handle had a terminal broke off. the wire may have touched something because the fuse was blown. Cleaned and tightened loose wire, replaced switch and fuse now it runs. For how long do not know.
wmg is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas EZGO


Thread Tools
Display Modes


Similar Threads
Thread Forum
2014 XRT 850 gas anyone have one. Gas Club Car
my new 2014 RXV Members Rides
2014 efi Gas Yamaha


All times are GMT -5. The time now is 08:22 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.