|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
01-15-2018, 05:51 PM | #1 |
Gone Wild
Join Date: Jun 2017
Location: Savannah, GA
Posts: 6,539
|
3PG Ezgo only runs at about 3/4 to full choke
My 1992 ezgo marathon with a 3PG engine and a brand new carb only runs at about 3/4 choke. When I first installed the carburetor a few days ago, it ran well at about half choke. Now it has gotten worse. I am using 128:1 gas ratio.
Any ideas? Luke |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
01-15-2018, 06:12 PM | #2 |
Test before replacing
Join Date: Aug 2013
Location: Ohio side of the Pennsylvania border.
Posts: 3,496
|
Re: 3PG Ezgo only runs at about 3/4 to full choke
Since somebody was running it at 50:1 mix, I would suspect a clogged exhaust.
|
01-15-2018, 07:54 PM | #3 |
Gone Wild
Join Date: Jun 2017
Location: Savannah, GA
Posts: 6,539
|
Re: 3PG Ezgo only runs at about 3/4 to full choke
So I should do a muffler BBQ?
Sent from my iPhone using Tapatalk |
01-15-2018, 07:58 PM | #4 |
Test before replacing
Join Date: Aug 2013
Location: Ohio side of the Pennsylvania border.
Posts: 3,496
|
Re: 3PG Ezgo only runs at about 3/4 to full choke
Can't hurt, but just as easy to disconnect the muffler to see what happens.
|
01-15-2018, 08:09 PM | #5 | |
Gone Wild
Join Date: Jun 2017
Location: Savannah, GA
Posts: 6,539
|
Re: 3PG Ezgo only runs at about 3/4 to full choke
Quote:
And yes, the previous owner used it at 50:1 for all of it's life until it quit working last year. Thanks, Luke |
|
01-15-2018, 08:10 PM | #6 |
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: 3PG Ezgo only runs at about 3/4 to full choke
Bad crank seals will allow air in and need to choke to make it run richer may need to check them out
|
01-15-2018, 08:25 PM | #7 |
Gone Wild
Join Date: Jun 2017
Location: Savannah, GA
Posts: 6,539
|
Re: 3PG Ezgo only runs at about 3/4 to full choke
|
01-16-2018, 10:23 AM | #8 |
Gone Wild
Join Date: Jun 2017
Location: Savannah, GA
Posts: 6,539
|
Re: 3PG Ezgo only runs at about 3/4 to full choke
|
01-16-2018, 05:24 PM | #9 |
Test before replacing
Join Date: Aug 2013
Location: Ohio side of the Pennsylvania border.
Posts: 3,496
|
Re: 3PG Ezgo only runs at about 3/4 to full choke
Ok. It could be sucking air somewhere else.
Crankshaft seals are most likely culprit, but could also be a case leak. A 2pg has to come out for seal replacement. I don't know about a 3pg. |
01-16-2018, 09:22 PM | #10 |
Not Yet Wild
Join Date: Aug 2012
Posts: 57
|
Re: 3PG Ezgo only runs at about 3/4 to full choke
Did you pull and clean the carb ask discussed in one of the earlier threads?
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Yamaha G1 Only Runs with full choke and full Throttle | Gas Yamaha | |||
Need full choke to get ezgo cart going when cold | Gas EZGO | |||
G1 only runs full choke | Gas Yamaha | |||
1989 EZGO - Only Runs on Choke | Gas EZGO | |||
G16 only runs full throttle with choke pulled | Gas Yamaha |