07-08-2018, 04:10 PM | #1 |
Not Yet Wild
Join Date: Jun 2018
Posts: 6
|
No spark on 2002 txt
Hello, Hoping for some help here. I picked up this cart, non running. The guy I bought it from was in the middle of the hei conversion and relocated the electrical to the rear cross bar under the seat. I been working on this thing and comparing what was done with wiring schematics. I’ve replaced the solenoid, pulsar, new battery and using an msd dual coil pack that came with it. For the life of me, I can’t get any spark. It turns over now but that’s all. I’ve identified two wires that are disconnected over near where the electrics where located, but can’t find or figure where or if they should be hooked up. They show no voltage or ground. The wires are a red one and a black one with ring terminals. I’ve checked both switches and they both check good, but no spark. Any help would be appreciated...thanks in advance!
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-09-2018, 06:08 AM | #2 |
Gone Wild
Join Date: Jul 2017
Location: East Central Missouri
Posts: 1,955
|
Re: No spark on 2002 txt
I don't recall many, if any, people who have had good luck with an HEI conversion on the 2 cylinder 4 cycle EZGO engines. I could be wrong because I only skimmed those threads. You might want to do a search for "ezgo hei" for more reading.
|
07-09-2018, 06:18 AM | #3 |
Not Yet Wild
Join Date: Jun 2018
Posts: 6
|
Re: No spark on 2002 txt
Thanks for the reply. I’ve skimmed a lot on here, and that’s kinda what I’m seeing. Seems to work well with the 2 strokes, but very few say that it worked for them on the 4’s. Guess I need to bite the bullet and buy an original igniter and coil. Thanks again.
|
07-09-2018, 12:44 PM | #4 |
Gone Wild
Join Date: May 2010
Location: Plainwell mi but from Ohio GO BUCKS!!!
Posts: 167
|
Re: No spark on 2002 txt
Aftermarket on Ebay and they're selling the same exact part at the ezgo store for $125.00
EZ Go Ignition Coil OE #26652-G01 replacement - EPIGC103 20 ratings $49.95 |
07-09-2018, 03:17 PM | #5 |
Not Yet Wild
Join Date: Jun 2018
Posts: 6
|
No spark on 2002 txt
Thanks...I’ll retrofit it back to stock and see how it goes.
|
07-09-2018, 07:54 PM | #6 |
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: No spark on 2002 txt
I would steer clear of after market electronic parts... I've seen and read about way to many bad right out of the box
|
07-09-2018, 09:23 PM | #7 |
Gone Wild
Join Date: May 2010
Location: Plainwell mi but from Ohio GO BUCKS!!!
Posts: 167
|
Re: No spark on 2002 txt
I thought I was buying a OEM part but when I got to the parts store she game me the after market and said it was all they sell. She still charged me $98.00.
|
07-15-2018, 05:47 PM | #8 |
Not Yet Wild
Join Date: Jun 2018
Posts: 6
|
Re: No spark on 2002 txt
Still fighting gremlins on this thing. New hei module as the other one tested bad at the auto parts store, new gm 3.1 v6 coil, new solenoid, new voltage regulator, new pulsar, new fully charged battery. During testing and ohming everything out, I found that the oil pressure switch seems to be faulty as it goes straight to ground, even while cranking which I read kills the spark, so I disconnected the lead to it. Here’s the thing, the new pulsar is testing the same during cranking. I’m getting 0.032 volts ac. While I was replacing it, I cleaned the rust off the outer ring of the flywheel with a wire brush so that I could set the gap. I set it at 0.03. Any ideas what’s going on? Did I get a bad pulsar? Completely confused with this thing.
|
07-15-2018, 05:56 PM | #9 |
Vintage tech
Join Date: Sep 2009
Location: South
Posts: 3,216
|
Re: No spark on 2002 txt
Put it back to stock. These things are easy to repair so why change it ?
I can only help you if it is stock. Tom |
07-15-2018, 06:01 PM | #10 |
Not Yet Wild
Join Date: Jun 2018
Posts: 6
|
Re: No spark on 2002 txt
I’m close to doing just that...but that pulsar coil has me confused as to why low output when it’s completely disconnected from everything else while testing.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2002 ezgo spark problems | Gas EZGO | |||
2002 ezgo intermittent spark | Gas EZGO | |||
2002 club car spark issues | Gas Club Car | |||
had spark, pulled engine, now no spark | Gas EZGO | |||
88 marathon new 79 dodge coil little spark then no spark? | Gas EZGO |