lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas EZGO
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV.



Post New Thread  Reply
Thread Tools Display Modes
Unread 09-10-2019, 05:48 AM   #1
Not Yet Wild
 
Join Date: Sep 2019
Posts: 2
Default 1992 EZGO 2 stroke fuel system replaced, ran great for 1 min then back to a turd

Hi everyone. I've got this old 2 stroke ezgo marathon I've been playing with and I'm looking for some next steps. For a while it would only run on full choke. Then it finally quit. I replaced the fuel filter, fuel lines, carb, and fuel pump. Stepped on it and it ran like a champ for about 1000ft. Then it lost power and right back to not moving.

Suggestions for what's next?
ConquerCustom is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 09-10-2019, 06:31 AM   #2
Gone Wild
 
LukeL's Avatar
Yamaha
 
Join Date: Jun 2017
Location: Savannah, GA
Posts: 3,921
Default Re: 1992 EZGO 2 stroke fuel system replaced, ran great for 1 min then back to a turd

I had the same problem for the longest time. It takes a lot of messing with them to get them to pump reliably, but once they do, itís usually great.

Is your pump mounted down on the engine case? I found that a lot of my fuel delivery issues ended up being the cheap Chinese carb.
LukeL is online now   Reply With Quote
Unread 09-10-2019, 08:18 AM   #3
lost in the woods
 
CP241's Avatar
Club Car
 
Join Date: Apr 2018
Location: GA
Posts: 2,884
Default Re: 1992 EZGO 2 stroke fuel system replaced, ran great for 1 min then back to a turd

Aftermarket carbs will do that.

Aftermarket fuel pumps can do that.

Remove the fuel line from the carb and put it in a jar. Step on the gas, is fuel actually pumping? It should fill pretty quickly. If so, take apart the old oem carb, clean it REALLY well and put it back on. Probably help a lot. Make sure you have a nice fat blue spark as well, may be coincidence and have a failing coil or something else unrelated.

If ita not pumping much or any gas, pull the fuel pump off and put your finger over the hole where it mounts. Step on the gas, you should feel a considerable amount of air pumping in and out of that hole. If not, crank seals are shot. If so, make sure the flange where the o ring of the fuel pump sits is clean. May be a bad pump. Can also try taking a length of hose off the inlet side of the pump into a jar of gas and make sure its sucking.
CP241 is online now   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas EZGO


Thread Tools
Display Modes


Similar Threads
Thread Forum
1992 EZGO 4 stroke wonít suck gas into fuel pump Gas EZGO
WTB a 1988-1992 2 stroke ezgo cart Golf Carts and Parts
My 1992 ezgo 2 stroke makeover Lifted Golf Carts
Need airbox for 1992 ezgo 2 stroke Golf Carts and Parts
New member..1992 Ezgo 2 stroke Gas EZGO


All times are GMT -5. The time now is 11:46 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2019, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.