|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
05-24-2010, 03:32 PM | #1 |
Not Yet Wild
Join Date: Jul 2009
Posts: 12
|
91 EZGO won't go, Where & how to look
My Son-in-law's 91 gas EZGO acts like the belt is missing. The motor runs fine and the belt actually looks pretty good but the cart won't move. It was running fine one minute and dead the next. Where should I start looking for the problem.
Thanks, Mike |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-24-2010, 08:28 PM | #2 |
Doin' the Wild Thang
Join Date: Mar 2010
Location: Greenville, AL
Posts: 1,063
|
Re: 91 EZGO won't go, Where & how to look
So the motor is running now but the cart is not moving? If the motor is not running that will take some more symptoms to figure out but if the engine is running and the cart is not moving we can narrow it down to the clutches or the rear end. Get back with us and let us know some more specifics...
|
05-24-2010, 09:45 PM | #3 |
Gone Wild
Join Date: Feb 2008
Location: Brooklyn, Michigan "Home of M.I.S."
Posts: 3,667
|
Re: 91 EZGO won't go, Where & how to look
Check the axle's at the hub could be stripped, pretty common.
|
05-25-2010, 12:07 AM | #4 |
Not Yet Wild
Join Date: Jul 2009
Posts: 12
|
Re: 91 EZGO won't go, Where & how to look
Thanks, I'll have an opportunity to look at it a little closer tomorrow. I'm going to assume that if I put it up on a stand the problem will review itself, then I can seek info on how to fix it.
Mike |
05-25-2010, 12:19 AM | #5 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: 91 EZGO won't go, Where & how to look
Actually a stripped hub will reveal itself on the ground but not in the air sometimes..... remove the wheel cover and axle nut dust cover if present to view the axle nut while somebody revs the cart in gear ..... the hub is stripped if the nut spins but the wheel does not ..... hope this helps
|
05-25-2010, 04:38 PM | #6 |
Not Yet Wild
Join Date: Jul 2009
Posts: 12
|
Re: 91 EZGO won't go, Where & how to look
Today I had a chance to actually see this cart for myself and the real problem is that it won't start. My son-in-law mistook the starter turning over the motor for it running and not moving. The belt and clutch and hubs seem fine. The compression is close to 120, the spark is good, gas seems to be flowing, and the exhaust doesn't seem to be plugged, so I'm thinking it's a carb problem. Am I missing anything?
|
05-25-2010, 04:52 PM | #7 |
......................
Join Date: Apr 2009
Location: FT Lauderdale FL.
Posts: 16,416
|
Re: 91 EZGO won't go, Where & how to look
Sounds right, pull the gas line off where it goes in to the carb , put the line in a bottle so gas goes not spray every where, take the plug wire off the plud so it will no crank up and take off on you, and turn the motor over to see if it is pumping gas first
|
05-25-2010, 05:22 PM | #8 |
Not Yet Wild
Join Date: Jul 2009
Posts: 12
|
Re: 91 EZGO won't go, Where & how to look
I did pull the gas line off just after the gas filter and it was pumping pretty good. I can do it at the carb too if you think its necessary.
Mike |
05-25-2010, 05:45 PM | #9 |
......................
Join Date: Apr 2009
Location: FT Lauderdale FL.
Posts: 16,416
|
Re: 91 EZGO won't go, Where & how to look
NO, just make sure the filter is good, just wanted to take the fuel pump out of the list of things.
can you tell us more about what happen, --you where driving the cart and it was running good and.??? |
05-25-2010, 07:07 PM | #10 |
Not Yet Wild
Join Date: Jul 2009
Posts: 12
|
Re: 91 EZGO won't go, Where & how to look
Car was running OK but not great. Stopped for a shot and it wouldn't move after that. The 3 year old drove while the 6 year old and Dad pushed it back to the barn.
Mike |