|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
08-31-2010, 02:40 PM | #1 |
Not Yet Wild
Join Date: Aug 2010
Posts: 2
|
Starts first time then wont till cooldown
I have a gas ezgo that will start the first time or two till it gets hot. Actually, it depends on how long you drive it. It take 5 to 10 minutes to cool down b4 it will start again. The solenoid is new. It will start by jumping the solenoid posts so I doubt it's the starter brushes. The solenoid will get hot while it's running. I left the key on while the engine was off and it did not get hot then. Is there a switch that is suppose to disengage the solenoid after the motor starts? Or maybe the key switch is wired wrong? Thanks in advance. Joe
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-31-2010, 02:49 PM | #2 |
Hammer Down !!!!
Join Date: Jun 2010
Location: Lake Geneva, WI
Posts: 2,681
|
Re: Starts first time then wont till cooldown
are you sure it's the correct type of solenoid? There are 2 types (and they both look basically the same) but one is designed to disengage when the motor starts (common for snowplow applications, etc) ... If you're running a standard type, anytime the gas pedal is pressed the solenois will be engaged, which would definitely overheat it
|
09-02-2010, 06:22 PM | #3 |
Not Yet Wild
Join Date: Aug 2010
Posts: 2
|
Re: Starts first time then wont till cooldown
Thanks for the attempt to help, but it looks like it's something else. I just changed out the solenoid and it still wont re-start after just a couple minutes of running. Seems like there should be another switch or sensor that tells the solenoid to disengage. I guess I could find a wiring diagram and trace it all out. Maybe whoever worked on it last might have mis-wired it. but I'm still open to suggestions. Thanks.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Wonder if I should not drive cart till repair | Electric Club Car | |||
97 club car wont start all the time | Gas Club Car | |||
95 Medalist Starts Every Time....Kinda | Gas EZGO | |||
93 Runs great till warmed up | Gas Club Car | |||
g-1 starts hard wont run at low speeds | Gas Yamaha |