|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
09-08-2010, 02:58 PM | #1 |
Getting Wild
Join Date: Jun 2009
Posts: 84
|
2001 Ezgo Hard to Start
Helping a friend with his 01 ezgo. Very hard to get running, Smell fuel as soon as you step on the gas pedal. almost sounds as if it is flooded. But once we get it to run it does run fine, But after it sits awhile it does it again. Any suggestions will be greatly appriciated.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-08-2010, 08:08 PM | #2 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 2001 Ezgo Hard to Start
sounds like it might be getting to much fuel pull park plug see if its all wet and sooty looking................this may sound dumb but when you go to start it slowly push gas pedal down until starter engages than stop see if it starts if not just slowly push pedal until you get to a spot where she cranks see if that helps at all.........i know its not a lot but its a start and you,ll be done in 10 minutes....................if plug is wet and sooty yes to much fuel.......could be fuel pump , fuel line, carb, have to try and eliminate them 1 at a time..................buy new plugs throw is see if it starts easier while they arn,t all crapped up....................................
|
09-08-2010, 08:46 PM | #3 |
Getting Wild
Join Date: Jun 2009
Posts: 84
|
Re: 2001 Ezgo Hard to Start
Thanks for replying, plugs are new, have pulled them a couple of times. they come out with what you might call a black soot on them. Will try to ease into the gas pedal, see what happens. He tried it again tonight, as soon as the engine turned over you can smell fuel. Was thinking the float in the carb might be out of wack or the fuel pump might be bleeding into the carb. Not really sure. Thanks again for the advise.
|
09-08-2010, 09:20 PM | #4 |
Getting Wild
Join Date: May 2009
Location: (winter) Homosassa,Fl / (summer) Bayonne,N.J./ Port Jervis, N.Y.
Posts: 131
|
Re: 2001 Ezgo Hard to Start
Had trouble starting mine, once it started and warmed up t would run ok.. I found mine was a plug wire grounding out, moved it away from the block and it starts fine now. It was actually the boot touching a manifold bolt.
|
09-08-2010, 10:43 PM | #5 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 2001 Ezgo Hard to Start
you can also try pinching your fuel line and cutting flow down some see if that helps, if new plugs are already sooty yes to much fuel.............
|
09-26-2010, 08:42 PM | #6 |
Getting Wild
Join Date: Jun 2009
Posts: 84
|
Re: 2001 Ezgo Hard to Start
Put a new fuel pump on. Did good for about 10 mimutes. then back to the same old routine. Carb loads up, if it sits for more than 10 mimutes. Acts like it's flooded. diconnect the fuel line and crank on it for a while and it will start. Could the floats be out of adjustment? Or some depree trapped somewhere? Thanks
|
09-26-2010, 10:37 PM | #7 |
Doin' the Wild Thang
Join Date: Mar 2010
Location: Greenville, AL
Posts: 1,063
|
Re: 2001 Ezgo Hard to Start
Sounds like either the float is getting gas in it and weighting it down lettin too much fuel in or the needle or seat is bad. If I'm not mistaken that float is probably plastic and is not adjustable. It could be simple as some trash in the seat. Either way looks like you need to break the carb. down to clean and inspect.
|
09-27-2010, 01:51 AM | #8 |
Getting Wild
Join Date: Jun 2009
Posts: 84
|
Re: 2001 Ezgo Hard to Start
I wasthinking it might be something like that. I'm going to break it down and see what I can find. Thanks for your help!
|
11-06-2010, 05:33 PM | #9 |
Getting Wild
Join Date: Jun 2009
Posts: 84
|
Re: 2001 Ezgo Hard to Start
Still have the same on going problem. Installed new battery, coil, fuel pump, solonoid, adjusted the valves. Had installed a new igniter this spring. Checked all connections and ground.
We hooked up a battery charger with a boost. Can get the cart started that way. But will die if you let off the gas pedal. But once the engine get warm the cart will start on it's own and will run most of the day. Any suggestions please ! I'm at a lost. |
11-06-2010, 06:16 PM | #10 |
Getting Wild
Join Date: Nov 2010
Location: California
Posts: 93
|
Re: 2001 Ezgo Hard to Start
Likely a dirty carb. Clean all jets: main and pivot. Remove jets, if you can, and ensure that the tiny holes are not clogged. To remove the main jet, you have to uninstall the carb.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
87 ez go hard to start | Gas EZGO | |||
G-1 hard start | Gas Yamaha | |||
Hard to start | Gas EZGO | |||
Hard to Start | Big Block Talk! | |||
Hard to start | Gas Club Car |