|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
04-07-2011, 08:20 AM | #1 |
Not Yet Wild
Join Date: Apr 2011
Posts: 1
|
1998 Robin EH29C Stops running no gas in filter
golf cart will run for awhile then stop. notice no gas going into fuel filter. took hose off. pored gas into hose put back to filter, ran awhile then stopped again. did this several times.finally took off filter. put a straight hose on. ran awhile then would stop.everytime i would take hose off and put gas in it and reattach it would run for 15 minutes or so then stop again was thinking fuel pump bad, any suggestions? thank you
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-07-2011, 09:19 AM | #2 |
Not Yet Wild
Join Date: Apr 2011
Location: Michigan
Posts: 18
|
Re: 1998 Robin EH29C Stops running no gas in filter
Pickup tube fell down inside fuel tank, plugged line or bad fuel pump are the likely suspects.
|
04-07-2011, 09:25 AM | #3 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,418
|
Re: 1998 Robin EH29C Stops running no gas in filter
A leaky vacuum tube can be the culprit. Runs from the bottom of the fuel pump to the engine case. This vacuum source is what pumps the fuel. Check the line for cracks and the things mark mentioned.
|
04-07-2011, 09:25 AM | #4 |
Not Yet Wild
Join Date: Dec 2010
Location: Minneapolis, Kansas
Posts: 66
|
Re: 1998 Robin EH29C Stops running no gas in filter
Take your fuel line that runs from your pump to the carb and take it off at the carb. crank the motor over and see if you are getting a full stream of fuel. If your not you need to check the hose from the pump to the engine block and make sure there isnt anything blocking it. If it is clean and you have a good vacum coming off that line then it is more than likely your pump.
|
04-07-2011, 11:16 AM | #5 |
Not Yet Wild
Join Date: Jan 2011
Location: Houston, Texas
Posts: 71
|
Re: 1998 Robin EH29C Stops running no gas in filter
I suffered this same problem earlier this year. I had the same symptoms, no fuel in the glass filter, it would run for about ten minutes then die. If I let it sit a while, it would start back up and run another ten minutes. I changed the fuel pump, checked the pickup tube, put a new vacuum line and fuel line on the cart, but it kept running for about ten minutes then would die with a fuel filter full of air. I finally decided to check the compression. I only had 120psi in both cylinders. When I looked into the low compression issue, I found both intake valves were out of adjustment. I spent 10 minutes adjusting the intake valves and all my problems went away. I then had 180 psi in both cylinders and the fuel pump would pump a steady stream of fuel when I took the output hose off the carb. If those intake valves don't completely close, you will not get the proper vacuum pulses which make the fuel pump operate. The valve lash is easy to check, I would check that first, before you start replacing a bunch of unnecessary items like I did.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
EH29C Robin Engine Rod Caps | Gas EZGO | |||
Robin EH29C carb setting | Gas EZGO | |||
Robin eh29c 295cc | Gas EZGO | |||
Robin eh29c | Gas EZGO | |||
Smoking EH29C Robin | Gas EZGO |