|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
08-13-2011, 10:20 PM | #1 |
Not Yet Wild
Join Date: Aug 2011
Posts: 8
|
89 ez go gas firing poblem
Ok for starters have great compression. finally got the the crank seals replaced and i pressurized the fuel system. The pump is pumping correctly and is in fact pumping fuel to the carb. i have pulled the spark plug and im getting good spark with a ngk plug and a champion plug, And the plug has some oil/gas on it. And now my problems is that i cant get it to fire and run for a couple of seconds after holding the choke and pressing the pedal for a while it will finally start and run for a moment then it falls on its face and wont start. then i can repeat this step and do it till the battery dies. HELP lol really ready to get this thing running.
Thanks alot |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-14-2011, 01:08 AM | #2 |
Gone Wild
Join Date: Feb 2011
Posts: 1,515
|
Re: 89 ez go gas firing poblem
Have you cleaned the carb ? Is you oil mix correct ?
|
08-14-2011, 08:20 AM | #3 |
Hammer Down !!!!
Join Date: Jun 2010
Location: Lake Geneva, WI
Posts: 2,681
|
Re: 89 ez go gas firing poblem
Yep - a simple carb cleaning should do the trick, but keep in mind that a cleaning is going to entail pulling the carb and disassembling it to ensure that you get ALL the jets completely cleaned out (just a little tiny bit of anything in even one jet will cause major starting and running issues with these) - here's a diagram of your carb to help out, I circled all the jets that need to be pulled and cleaned. The best method is to use a can of spray carb cleaner (the one with the tube so you can get a tight hard stream out of it) and make SURE you wear eye protection as the stuff burns like CRAZY. Pull each jet, spray them out thoroughly to make sure all the orifice(s) are clean, then spray the seats to ensure there's no stuff up there, also it's a good idea to clean out the float bowl thoroughly, reassemble and you should be just fine.
|
08-14-2011, 11:52 AM | #4 |
Not Yet Wild
Join Date: Aug 2011
Posts: 8
|
Re: 89 ez go gas firing poblem
Ok i have cleaned the carb twice ive even disasembled it. Then i took the intake tube off cleaned it then the reed valves out and cleane them. Still doesnt fire.
|
08-14-2011, 12:28 PM | #5 |
Not Yet Wild
Join Date: Jul 2011
Location: puyallup washington
Posts: 25
|
Re: 89 ez go gas firing poblem
hi blaze man, did you take out the needle seat in the carb? it has a little rubber seal on the end of it. it will get stuck and not let in any fuel into the carb bowl. if you don't know where it is you might not know to take it out. one thing you can do to make sure you have fuel getting into the carb from your pump is to with the carb on the motor loosen up the bowl and see if you actually have fuel there. hope any of this helps.
|
08-14-2011, 02:36 PM | #6 |
Not Yet Wild
Join Date: Aug 2011
Posts: 8
|
Re: 89 ez go gas firing poblem
if its the right needle you talking about it the one under the float. I took it out and ran carb cleaner thru it all. i dont know what else i could do. any suggestions.
|
08-14-2011, 05:03 PM | #7 |
Not Yet Wild
Join Date: Jul 2011
Location: puyallup washington
Posts: 25
|
Re: 89 ez go gas firing poblem
did you try taking the bowl off while still on the motor and craking it over to make sure you are getting fuel into the carb?
|
08-14-2011, 06:02 PM | #8 |
Hammer Down !!!!
Join Date: Jun 2010
Location: Lake Geneva, WI
Posts: 2,681
|
Re: 89 ez go gas firing poblem
longshot, but try turning your fuel mixture screw all the way in and then backing it out 1.5 turns, see if that somehow got jazzed up - also, you should try the carb/fuel check talked about above, I've seen pumps that blew gas when unhooked from the carb but had a tiny tear in the diaphragm and once hooked up, actually WEREN'T pumping enough to keep the cart running
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
G14 Firing Problem | Gas Yamaha | |||
back firing | Gas Club Car | |||
98 ST350, not firing | Gas EZGO | |||
not firing | Gas EZGO | |||
charging poblem | Electric Club Car |