|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
09-19-2011, 06:23 PM | #1 |
Not Yet Wild
Join Date: Sep 2011
Posts: 6
|
Robin 244cc fuel problem
Cart will not run longer than 2 minutes. I've changed the fuel pump, lines and filter, as well as a new spark plug. It was running fine, then POOF! like magic, it seemed to run out of fuel. Any ideas out there?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-19-2011, 06:38 PM | #2 |
Gone Wild
Join Date: Oct 2010
Location: Lawrenceburg Ky.
Posts: 1,771
|
Re: Robin 244cc fuel problem
check your gas cap and air filter.
45 ACP because shooting twice is silly. |
09-19-2011, 07:26 PM | #3 |
Not Yet Wild
Join Date: Sep 2011
Posts: 6
|
Re: Robin 244cc fuel problem
Will check that fuel cap. Makes too much sense. Thnx much.
44 MAG. Just get close... |
09-20-2011, 12:51 PM | #4 |
Not Yet Wild
Join Date: Sep 2011
Posts: 6
|
Re: Robin 244cc fuel problem
Fuel cap did not seem to fix problem. Even ran it without cap and air filter just to trouble shoot.
Any other suggestions, from anybody? thnx. |
09-20-2011, 02:12 PM | #5 |
Gone Wild
Join Date: Jul 2008
Location: Reddick IL
Posts: 11,220
|
Re: Robin 244cc fuel problem
Take a heavy screw driver and tap on the carb it may have a sticky float.
A little more information will help? Does it start right back up, is the spark plug wet when it quits, is it hot, is the exhaust pipe hot or cold when it quits? |
09-20-2011, 02:21 PM | #6 |
Gone Wild
Join Date: Aug 2011
Location: Bunnell, Florida
Posts: 2,408
|
Re: Robin 244cc fuel problem
Not sure on this, but does yours have a filter in the tank, also?
|
09-20-2011, 02:24 PM | #7 |
Not Yet Wild
Join Date: Sep 2011
Posts: 6
|
Re: Robin 244cc fuel problem
Yes, it starts back up within 15-20 seconds. It does not run long enough to get hot(like a boil over with a pumper). Have not grabbed the exhaust to see if it's warm.
Will try the stuck float thing. thnx. P.S. Is the carb a pain to rebuild? Haven't done one for 30+ years. |
09-20-2011, 02:28 PM | #8 |
Not Yet Wild
Join Date: Sep 2011
Posts: 6
|
Re: Robin 244cc fuel problem
>@ Simple Man- no filter in the tank. Thnx for the suggestion.
|
09-20-2011, 03:22 PM | #9 |
Respect the Cart
Join Date: May 2010
Location: Rocky Mount, Virginia
Posts: 2,190
|
Re: Robin 244cc fuel problem
If the regulator fails, the generator puts out 18 volts which overheats the ignitor and causes it to shut down until it cools. Nice easy test to rule this out. Jack up the back or remove the drive belt and run the engine at a about 2000 rpm. Now measure the battery voltage. If it is less than 17 volts I have just wasted 10 minutes of your life.
Dave |
09-20-2011, 07:38 PM | #10 |
Not Yet Wild
Join Date: Sep 2011
Posts: 6
|
Re: Robin 244cc fuel problem
>@ Dave- I'll check the voltage again. Last time I checked it (for battery problem) it read 14.8 volts at the battery while running.
ALSO- none of the post for help are a waste of my time, and all are greatly appreciated. This old dog can be taught, or refreshed, of things forgotten about over the years. Thank you again..... |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
looking for a robin 244cc or replacment! | Gas EZGO | |||
1979 Robin 244cc 2pg 2stroke, electrical problem | Gas EZGO | |||
244cc Robin can't keep running | Gas EZGO | |||
robin 244cc compression | Gas EZGO | |||
WTB robin 244cc in KY | Golf Carts and Parts |