09-06-2013, 05:39 PM | #1 |
Not Yet Wild
Join Date: Apr 2013
Posts: 64
|
91 2cycle gen
my 91's start/gen won't turn with the belt on and the wires get red hot,what should I check? thanks
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-08-2013, 06:07 PM | #2 |
Gone Wild
Join Date: May 2013
Posts: 320
|
Re: 91 2cycle gen
Prob froze up geny/starter. Remove and do a rebuild if it is not to far gone. If so, new starter/geny.
|
09-09-2013, 10:41 AM | #3 |
Gone Wild
Join Date: Aug 2011
Location: Bunnell, Florida
Posts: 2,408
|
Re: 91 2cycle gen
Does the engine turn Ok by hand? The belt could also be too tight. That will make the S-G harder to turn. You can also check that the insulators where the cables mount have not failed and letting them short out to the case. That's about all I can think of to check.
|
09-18-2013, 03:35 PM | #4 |
Not Yet Wild
Join Date: Aug 2013
Location: NJ
Posts: 9
|
Re: 91 2cycle gen
I had the same problem on a 90 Marathon, turned out the cart had been sitting long enough that the engine was bound up. I pulled the spark plug and put in a bit of 2 stroke oil and then was able to turn the crankshaft by hand using the drive clutch to hold onto and get it broken loose. Before I did that I loosened the starter gen belt to see if it would spin at all. After i could turn the crankshaft fairly easily with no plug i tightened the belt up and has the starter gen spin the motor. Did this for a few spans of about 20 seconds and that got the motor spinning freely. Put the plug in and good to go.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
reeds for a 2cycle | Golf Cart Racing | |||
Looking for some 81 2cycle parts.. . | Golf Carts and Parts | |||
1979 2cycle | Gas EZGO | |||
88 2cycle help | Gas EZGO | |||
Need more speed 88 ez go 2cycle | Gas EZGO |