lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas EZGO
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV.



Post New Thread  Reply
Thread Tools Display Modes
Unread 10-06-2013, 07:28 PM   #1
Gone Wild
 
frodrummer's Avatar
E-Z-GO
 
Join Date: Sep 2012
Location: Savannah MO
Posts: 206
Default Marathon vibration and noise

81 marathon. Has a strange noise and vibration at take off and when coming up on top speed. When I hit mid throttle, the noise/vibration goes away, then slowly returns when approaching top speed. I thought it was the drive clutch, but installed a new comet clutch and still have both symptoms. The noise sounds like its coming from the rear passenger axle area. With the rear end jacked up, no noise or vibration. There is a moderate amount of play in the pass side axle. I can move the tire forward and backward about 2.5 inches in both directions. I also grabbed the tire and pulled outward and noticed about a 1/4" of movement in and out. Is this movement normal? I noticed the drivers side does not move in any direction, so I'm guessing something in the pass side is fouled up.

I pulled off the hub, snap ring, and pulled the axle and bearing out. I didn't see any excessive wear on the splines, and the bearing spins fairly well. Not sure what to look for though.????

I also checked the drums and shoes for some abnormality.... It looks good to me.

I do believe my motor mounts could stand to be replaced, which I'm sure is adding to my vibration woes.

Any advice would be most helpful.
frodrummer is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 10-07-2013, 01:55 AM   #2
Gone Wild
 
Join Date: Feb 2011
Posts: 1,481
Default Re: Marathon vibration and noise

I think you found it Ford Motor mounts would be my answer. I've replaced them in both of mine for the same reason and the noise went away.

LOU
racin161 is offline   Reply With Quote
Unread 10-07-2013, 09:52 PM   #3
Gone Wild
 
Join Date: May 2013
Posts: 320
Default Re: Marathon vibration and noise

Mounts will do it but i would also check all the mountings for your muffler as they will crack mounts even were you can't see and give nasty vibrations...
Had to weld up both side on my 91 marathon.
redcloud is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas EZGO


Thread Tools
Display Modes


Similar Threads
Thread Forum
94 Marathon Oil Leak/Vibration Gas EZGO
1980 Marathon Vibration Help Gas EZGO
1991 Club Car 36v vibration and noise coming from motor input shaft Electric Club Car
Bad vibration/noise from driven clutch at higher speeds.. Gas EZGO
Baterry Charger Noise / Vibration ? Electric EZGO


All times are GMT -5. The time now is 04:16 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2018, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.