08-31-2016, 02:54 PM | #1 |
Not Yet Wild
Join Date: Jun 2016
Posts: 9
|
starts runs good then won't start
I have a 1976 model d amf harley three wheel golf cart.It sits all week at our camp but starts right up on saturday.It runs strong but if I stop somewhere it takes three to five minutes to turn over again.the starter turns and i checked the plug and it was firing.any help would be welcomed.thanks.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-01-2016, 07:51 AM | #2 |
Gone Wild
Join Date: May 2011
Location: Pittsburgh
Posts: 2,950
|
Re: starts runs good then won't start
Sounds like you may be overheating. You way want to check your fan out. The older Harley ones are more durable than the later Columbia ones but still, can't hurt to check.
Check all of your engine fins for cleanliness and everything else with airflow for that matter. May want to check all of your wiring connection points too to make sure nothing is arching. |
09-01-2016, 08:24 AM | #3 |
Not Yet Wild
Join Date: Jun 2016
Posts: 9
|
Re: starts runs good then won't start
thanks.we'll be at camp this weekend.i'll check it out.just one question,where would the fan be on the engine.
|
09-01-2016, 09:33 AM | #4 |
Gone Wild
Join Date: May 2011
Location: Pittsburgh
Posts: 2,950
|
Re: starts runs good then won't start
The fan is right in the center of front of the motor. Under the screen. Pop that screen off and you'll see the fan in the housing. The points will be in the middle, covered, with a wire coming from underneath and going to the coil. No need to monkey with that. Make sure that fan isn't loose and that all of the blades are in place. I had two fans kinda disintegrate but those were later years' carts. Make sure everything is cleaned up real nice.
Also, giving this some more thought, I would suspect a failing and overheating coil also but, as you are getting spark when the thing isn't running probably not. |
09-01-2016, 09:29 PM | #5 |
Gone Wild
Join Date: Aug 2007
Location: North Texas
Posts: 2,312
|
Re: starts runs good then won't start
Does the engine turn with the starter or does the starter turn and the belt slips after running for a while. If you cannot turn the engine over by hand lochlin has it right.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
starts and runs then it wont start | Gas golf carts | |||
2006 PDS runs good then runs slow | Electric EZGO | |||
engine starts, runs rough, stumbles, dies and won' t start | Gas Club Car | |||
Ezgo workhorse runs good then starts to sputter and run bad | Gas EZGO | |||
G1 starts hard, then runs fast only | Gas Yamaha |