|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
10-18-2015, 08:29 PM | #1 |
Gone Wild
Join Date: May 2010
Location: OHIO
Posts: 1,517
|
what's the issue
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-18-2015, 09:33 PM | #2 |
G8 Specialist
Join Date: Jun 2009
Location: Phoenix
Posts: 7,799
|
Re: what's the issue
First I'd use a spark plug tester to see if the plug is sparking on every compression stroke.
Second, I'd check to see if the exhaust valve rocker arm is moving when the motor turns over. And, the motor IS turning over the correct direction, Right? |
10-18-2015, 10:00 PM | #3 |
Gone Wild
Join Date: May 2010
Location: OHIO
Posts: 1,517
|
Re: what's the issue
The clutch is spinning towards the front of the cart,was getting spark until it started to do this but ill have to check it again
|
10-19-2015, 10:12 AM | #4 |
Gone Wild
Join Date: May 2010
Location: OHIO
Posts: 1,517
|
Re: what's the issue
One rocker is a lil loose not much though but both are moving and its getting some spark but not a hole lot since the motor does not spin fast
|
10-19-2015, 03:22 PM | #5 |
G8 Specialist
Join Date: Jun 2009
Location: Phoenix
Posts: 7,799
|
Re: what's the issue
Not being there, its hard for me to say, but I'm guessing its an ignitor issue!
|
10-19-2015, 07:05 PM | #6 |
Gone Wild
Join Date: May 2010
Location: OHIO
Posts: 1,517
|
Re: what's the issue
The igniter will cause the motor to spin slow ?
|
10-19-2015, 10:01 PM | #7 |
G8 Specialist
Join Date: Jun 2009
Location: Phoenix
Posts: 7,799
|
Re: what's the issue
Looks like its turning over on the starter just fine.
If you have intermitant spark, thats your problem. Also, is the float bowl full of gas? |
10-19-2015, 10:34 PM | #8 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: what's the issue
Check throttle for opening with gas pedal, then spray carb/brake cleaner down carb hole. That eliminates "air & fuel" from the triangle of fire (spark/heat is third side of triangle). Whats compression? Motor spinning slow?
|
10-20-2015, 07:54 AM | #9 |
Gone Wild
Join Date: May 2010
Location: OHIO
Posts: 1,517
|
Re: what's the issue
It has gas in the bowl because sometimes it turns over (normal) and spits gas out the carb, but turns over real sluggish
I put my hand in a cup position over the carb and it seams to run lil faster without that hickup/hesitation but i get a cough of gas once in awhile |
10-20-2015, 09:00 AM | #10 |
Sometime's............
Join Date: Oct 2007
Location: Tacoma Washington
Posts: 11,875
|
Re: what's the issue
When you put on the new negative battery cable, did you attatch the small 18 gauge jumper lead to the wire harness?
|
|
|
Similar Threads | ||||
Thread | Forum | |||
05 Bad Boy Issue | Gas golf carts | |||
OBC Issue? | Electric Club Car | |||
G16 issue | Gas Yamaha | |||
yet another issue | Electric EZGO | |||
Charging Issue/ Battery Issue? | Electric EZGO |