|
|
|||||||
| Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
  |
|
|
Thread Tools | Display Modes |
07-08-2016, 05:49 PM
|
#1 |
|
Not Yet Wild
Join Date: Mar 2012
Location: https://t.me/pump_upp
Posts: 69
|
Yamaha G1 no power question
The cart started loosing power until one day it would not start. Checked and was getting no fuel. Replaced seal on fan side and bam pumping fuel. cart started and ran. bad to no power. Would not even pull a small hill. Rebuilt top end with new jug, new piston and rings. all new gaskets. A little better but still no power. Any ideas or what to do next.???
|
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
07-08-2016, 06:44 PM
|
#2 |
|
Sometime's............
 Join Date: Oct 2007
Location: Tacoma Washington
Posts: 11,875
|
Re: Yamaha G1 no power question
If your G1 has exhaust valve and linkage, make shure it is hooked up and opening and closing as needed.
|
|
|
|
|
07-08-2016, 07:17 PM
|
#3 |
|
Not Yet Wild
Join Date: Mar 2012
Location: https://t.me/pump_upp
Posts: 69
|
Re: Yamaha G1 no power question
none that i see it has a hose that runs from exhaust to the oil pump
|
|
|
|
|
07-09-2016, 10:12 AM
|
#4 |
|
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: Yamaha G1 no power question
It's right on the exhaust manifold not on the muffler.....when you did the rebuild did you replace the other seal? Are clutches functioning properly?
|
|
|
|
|
07-09-2016, 10:30 AM
|
#5 |
|
Not Yet Wild
Join Date: Mar 2012
Location: https://t.me/pump_upp
Posts: 69
|
Re: Yamaha G1 no power question
I replaced all seals that came with te kit. not sure about clutch. it spins up bringing the belt all the way up.
|
|
|
|
|
07-09-2016, 10:40 AM
|
#6 | |
|
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: Yamaha G1 no power question
Quote:
|
|
|
|
|
|
07-09-2016, 10:41 AM
|
#7 |
|
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: Yamaha G1 no power question
also do a compression test with muffler on and then take muffler off it drops with muffler off you may have a clogged muffler
|
|
|
|
|
07-09-2016, 10:42 AM
|
#8 |
|
Not Yet Wild
Join Date: Mar 2012
Location: https://t.me/pump_upp
Posts: 69
|
Re: Yamaha G1 no power question
Okay first I will apologize for being dummy but which is the secondary...front by motor or back by rear end??
|
|
|
|
|
07-09-2016, 10:48 AM
|
#9 |
|
Gone Wild
Join Date: Jun 2015
Location: NW Iowa
Posts: 1,669
|
Re: Yamaha G1 no power question
secondary is the one on the differential primary is on the motor
|
|
|
|
|
07-09-2016, 10:49 AM
|
#10 |
|
Not Yet Wild
Join Date: Mar 2012
Location: https://t.me/pump_upp
Posts: 69
|
Re: Yamaha G1 no power question
Thank you going out to see now
|
|
|
|
|
|
||||||
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| Yamaha g22 has no power! | Gas Yamaha | |||
| more power for my yamaha | Gas Yamaha | |||
| Yamaha G16 Gas power | Gas EZGO | |||
| yamaha power kit | Gas Yamaha | |||
Linear Mode
